太阳光光催化降解水性油墨废水的实验研究

doi:10.11894/iwt.2018-0906

工业水处理 ›› 2019, Vol. 39 ›› Issue (11): 26-30. doi: 10.11894/iwt.2018-0906

太阳光光催化降解水性油墨废水的实验研究

魏婕(),刘树鑫,邓家旺,蒋毓婷

沈阳建筑大学市政与环境工程学院, 辽宁沈阳 110168

收稿日期:2019-09-11 出版日期:2019-11-20 发布日期:2019-11-22
作者简介:魏婕(1984-),副教授,博士。电话:13190068235, E-mail:weijie0307@126.com
基金资助:
国家自然科学基金项目(51108277);辽宁省自然科学基金项目(20170540773);辽宁省教育厅科学研究项目(LJZ2016032);沈阳建筑大学科学研究项目(2017027);沈阳建筑大学青年基金项目(2015028);沈阳建筑大学学科涵育计划项目(XKHY2-60)

Experimental study on photocatalytic degradation of water-based ink wastewater by sunlight

Jie Wei(),Shuxin Liu,Jiawang Deng,Yuting Jiang

School of Municipal and Environmental Engineering, Shenyang Jianzhu University, Shenyang 110168, China

Received:2019-09-11 Online:2019-11-20 Published:2019-11-22
Supported by:
国家自然科学基金项目(51108277);辽宁省自然科学基金项目(20170540773);辽宁省教育厅科学研究项目(LJZ2016032);沈阳建筑大学科学研究项目(2017027);沈阳建筑大学青年基金项目(2015028);沈阳建筑大学学科涵育计划项目(XKHY2-60)

摘要/Abstract

摘要：

采用颜料蓝1为原料配制模拟水性油墨废水，在太阳光下对基底材料、水性油墨颜料初始浓度、光照强度进行光催化氧化影响作用的研究。结果表明：铝板作为基底的光催化降解效果强于其他板材；颜料蓝1质量浓度为75 mg/L、光强为65.32 W/m²时，水中污染物最高去除率可达98%；质量浓度为150 mg/L、光强为39.16 W/m²时，水中污染物最大去除量为360.7 mg/L；太阳光光催化反应体系受光照波动性影响较大，其中光照强度越强则水性油墨废水降解效果越显著。

关键词: 太阳光光催化氧化, 水性油墨废水, 光照强度, 基底材料

Abstract:

The pigment blue 1 solution was used as the simulated aqueous ink wastewater. The effects of the substrate materials, initial concentration of water-based ink wastewater and light intensity on the photocatalytic oxidation were studied under sunlight. The results show that the photocatalytic degradation of aluminum plate as substrate is stronger than other plates. When the concentration of the wastewater is 75 mg/L and the light intensity is 65.32 W/m², the highest removal rate of pollutants in the wastewater can reach 98%. When the concentration of wastewater is 150 mg/L and the light intensity is 39.16 W/m², the maximum removal of pollutants in the wastewater is 360.7 mg/L. The photocatalytic reaction system of sunlight is greatly affected by the fluctuation of illumination. The stronger the illumination intensity is, the more significant the degradation effect of aqueous ink wastewater is.

Key words: solar photocatalytic oxidation, aqueous ink wastewater, light intensity, base material

中图分类号:

X703

魏婕,刘树鑫,邓家旺,蒋毓婷. 太阳光光催化降解水性油墨废水的实验研究[J]. 工业水处理, 2019, 39(11): 26-30.

Jie Wei,Shuxin Liu,Jiawang Deng,Yuting Jiang. Experimental study on photocatalytic degradation of water-based ink wastewater by sunlight[J]. Industrial Water Treatment, 2019, 39(11): 26-30.

https://www.iwt.cn/CN/Y2019/V39/I11/26

图/表 4

图1 实验装置

图2 3种金属板为基底光催化膜对水性油墨废水的降解情况比较

图3 水性油墨废水浓度对光催化处理效率的影响

图4 不同光照下的水性油墨废水降解情况

参考文献 27

1	姚瑞玲, 高巧侠, 朱凤平. 浅谈环保油墨[J]. 广东印刷, 2012, (3): 43- 45. doi: 10.3969/j.issn.1005-7463.2012.03.046
2	孙永泰. 环保型水性油墨的研究与市场展望[J]. 上海造纸, 2008, 39 (2): 56- 58. doi: 10.3969/j.issn.1674-6937.2008.02.013
3	廖绍华.水性油墨废水处理技术的研究[D].杨凌:西北农林科技大学, 2008. URL
4	银洲, 张建强. 二氧化钛光催化降解环境内分泌干扰物技术的研究进展[J]. 水处理技术, 2013, 39 (1): 24- 28. doi: 10.3969/j.issn.1000-3770.2013.01.005
5	Chong M N , Jin B , Chow C W , et al. Recent developments in photocatalytic water treatment technology:a review[J]. Water Research, 2010, 44 (10): 2997- 3027. doi: 10.1016/j.watres.2010.02.039
6	Reza K M , Kurny A , Gulshan F . Parameters affecting the photocatalytic degradation of dyes using TiO₂:a review[J]. Applied Water Science, 2017, 7 (4): 1569- 1578. doi: 10.1007/s13201-015-0367-y
7	唐杰, 吴赞敏. TiO₂光催化氧化技术在印染废水处理中的研究进展[J]. 印染助剂, 2014, 31 (2): 10- 14. doi: 10.3969/j.issn.1004-0439.2014.02.002
8	何翔, 田晓梅, 陈艳. 负载TiO₂织物的制备及其太阳光催化活性研究[J]. 产业用纺织品, 2005, 23 (8): 27- 30. doi: 10.3969/j.issn.1004-7093.2005.08.007
9	吴学深, 夏东升, 陆晓华, 等. 光催化氧化水处理技术中光源的研究进展[J]. 化工环保, 2006, 26 (5): 390- 394. doi: 10.3969/j.issn.1006-1878.2006.05.011
10	Zainizan Sahdan M , Nayan N , Haimi Dahlan S , et al. Sol-gel synthesis of TiO₂ thin films from in-house nano-TiO₂ powder[J]. Advances in Materials Physics and Chemistry, 2012, 2 (4): 16- 20. doi: 10.4236/ampc.2012.24B005
11	单志强, 王晓林. La³⁺掺杂及载体类型对纳米TiO₂薄膜光催化活性的影响[J]. 水处理技术, 2006, 32 (1): 30- 32. doi: 10.3969/j.issn.1000-3770.2006.01.008
12	陈建华, 赵翠华, 龚竹青, 等. 不同载体表面负载TiO₂薄膜的离子掺杂研究[J]. 工业催化, 2005, 13 (12): 52- 57. doi: 10.3969/j.issn.1008-1143.2005.12.012
13	赵翠华, 陈建华, 单志强. 不同载体对负载TiO₂薄膜光催化活性影响的实验研究[J]. 工业用水与废水, 2004, 35 (3): 15- 17. doi: 10.3969/j.issn.1009-2455.2004.03.005
14	Fox M A , Dulay M T . Heterogeneous photocatalysis[J]. Chemical Reviews, 1993, 93 (1): 341- 357. URL
15	Akerdi A G , Bahrami S H , Arami M , et al. Photocatalytic discoloration of Acid Red 14 aqueous solution using titania nanoparticles immobilized on graphene oxide fabricated plate[J]. Chemosphere, 2016, 159:293- 299. doi: 10.1016/j.chemosphere.2016.06.020
16	Lu C S , Mai F D , Wu C W , et al. Titanium dioxide-mediated photocatalytic degradation of Acridine Orange in aqueous suspensions under UV irradiation[J]. Dyes and Pigments, 2008, 76 (3): 706- 713. doi: 10.1016/j.dyepig.2007.01.009
17	龚艳伟, 李晓秀, 樊颜波. 不同材料负载Ani/TiO₂光降解印染废水[J]. 环境工程学报, 2013, 7 (7): 2641- 2647. URL
18	Habibi M H , Talebian N . Photocatalytic degradation of an azo dye X6G in water:A comparative study using nanostructured indium tin oxide and titanium oxide thin films[J]. Dyes and Pigments, 2007, 73 (2): 186- 194. doi: 10.1016/j.dyepig.2005.11.006
19	吴琼.负载型TiO₂光催化剂的制备及其处理印染废水的试验研究[D].哈尔滨:哈尔滨工程大学, 2014. URL
20	耿静漪.负载型二氧化钛光催化降解染料的研究[D].苏州:苏州大学, 2012. URL
21	高倩.染料敏化二氧化钛可见光光催化降解有机污染物研究[D].天津:天津理工大学, 2011. URL
22	Malato S , Fernández-Ibánez P , Maldonado M I , et al. Decontamination and disinfection of water by solar photocatalysis:Recent overview and trends[J]. Catalysis Today, 2009, 147 (1): 1- 59. URL
23	何陆春.偶氮染料的太阳光催化氧化降解及其染色废水的回用[D].天津:天津工业大学, 2006. URL
24	Guo J , Dong C , Zhang J , et al. Biogenic synthetic schwertmannite photocatalytic degradation of acid orange 7(AO7) assisted by citric acid[J]. Separation and Purification Technology, 2015, 143:27- 31. doi: 10.1016/j.seppur.2015.01.018
25	Bahnemann D . Photocatalytic water treatment:solar energy applications[J]. Solar Energy, 2004, 77 (5): 445- 459. doi: 10.1016/j.solener.2004.03.031
26	Ochuma I J , Fishwick R P , Wood J , et al. Optimisation of degradation conditions of 1, 8-diazabicyclo[5.4.0] undec-7-ene in water and reaction kinetics analysis using a cocurrent downflow contactor photocatalytic reactor[J]. Applied Catalysis B:Environmental, 2007, 73 (3/4): 259- 268. URL
27	Behnajady M A , Modirshahla N , Daneshvar N , et al. Photocatalytic degradation of an azo dye in a tubular continuous-flow photoreactor with immobilized TiO₂ on glass plates[J]. Chemical Engineering Journal, 2007, 127 (1/2/3): 167- 176. URL

[1]	赵忠强, 芦小山, 左卫雄. 电氧化法处理水性油墨废水的研究[J]. 工业水处理, 2015, 35(7): 72-75.
[2]	杨鹏, 王中琪, 王军. 酸析-电催化法处理水性油墨废水的试验研究[J]. 工业水处理, 2013, 33(6): 51-54.

选择文件类型/文献管理软件名称

选择包含的内容

太阳光光催化降解水性油墨废水的实验研究

Experimental study on photocatalytic degradation of water-based ink wastewater by sunlight

RichHTML

可视化

被引次数

摘要/Abstract

引用本文

使用本文

图/表 4

参考文献 27

相关文章 2

编辑推荐

Metrics

本文评价

模态框（Modal）标题

选择文件类型/文献管理软件名称

选择包含的内容

太阳光光催化降解水性油墨废水的实验研究

Experimental study on photocatalytic degradation of water-based ink wastewater by sunlight

RichHTML

可视化

被引次数

摘要/Abstract

引用本文

使用本文

图/表 4

参考文献 27

相关文章 2

编辑推荐

Metrics

本文评价