高分子复合絮凝剂对活性印染废水的脱色性能研究
收稿日期: 2005-09-02
修回日期: 2005-09-02
网络出版日期: 2010-10-01
基金资助
上海市教委青年基金资助项目(03DQ26)
Study on the decolouration property of polymeric complex flocculants for active dyeing wastewater
Received date: 2005-09-02
Revised date: 2005-09-02
Online published: 2010-10-01
就几种高分子复合絮凝剂对活性染料废水的脱色性能进行了研究。当聚丙烯酰胺(PAM)的阳离子度为50%时,脱色率可达到90%以上,过多的阳离子会导致胶体颗粒重新稳定;1mg/L相对分子质量为1.2×107的PAM与150mg/LPAC复合可达到98.2%的最佳脱色效果,分子链过长的PAM分子由于空间位阻效应使颗粒间互相排斥;1mg/L壳聚糖(CTS)与100mg/LPAC复合后脱色率即可大于90%,过多的CTS分子因吸附空位的饱和无法发挥作用。通过SEM观察发现在PAC单纯的电中和作用下,絮体呈较为平坦的均匀连续絮状形态。加入有机高分子絮凝剂后,由于分子链的桥联卷扫作用,呈现出不同特点的聚集形态,形成比表面很大的絮体,从而强化对颗粒的吸附和架桥作用。
霍宇凝, 薛莉, 袁虹, 王静华, 顾晓蔚 . 高分子复合絮凝剂对活性印染废水的脱色性能研究[J]. 工业水处理, 2006 , 26(1) : 33 -35,39 . DOI: 10.11894/1005-829x.2006年.26(01).33
The decoloration property of several complex flocculants for active dyeing wastewater is discussed. When the concentration of PAM cationis 50%, 1mg/LPAM will promote the decolouration to be over 90%. The supe rabundant cations will cause the colloid stable again. The excellent decolouration rate can be obtained while 1 mg/L PAM (Mw=1.2×10 7 ) and 150 mg/L PAC is complex. The overlong molecular chain can produce the repulsion between particles because of the sterically hindered effect. The decolouration of 1 mg/L CTS + 100 mg/L PAC is over 90%. The redundant CTS molecular can not elaborate effect for the adsorptive space is already saturated. It is observed by SEMthat the flocculus produced with PAC is continuous, and the one produced by several polymeric flocculants is different. The much larger specific surface area can enhance the bridging and sweeping effect to the particles.
Key words: polyacrylamide; chitosan; polyaluminum chloride; flocculants; decolouration
[1] 肖瑞德. 印染废水的混凝脱色实验研究[J]. 化学反应工程与工 艺, 2002, 18(3) : 254-259.
[2] 黎载波, 王国庆, 邹龙生. 有机高分子絮凝剂在印染废水处理中 的应用[J]. 工业水处理, 2003, 23(4) : 14-17.
[3] 赵谨. 国内有机高分子絮凝剂的开发及应用[J].水处理技术 2003, 30(3): 9-12.
[4] 顾学芳,张跃军, 陈伟忠, 等. 阳离子絮凝剂 PDA的合成与应用研究[J]. 工业水处理, 2001, 21(1) : 22-25.
[5] 赵华章. 阳离子型高分子絮凝剂 PDMDAAC 与 P
[DMDAAC-AM] 的合成及分析[J]. 精细化工, 2001, 18(11) : 645-649.
[6] 丁忠浩. 有机废水处理技术及应用
[M]. 北京: 化学工业出版社, 2002. 58-60.
[7] Kawamuca Y, Yoshida H, Asai S, et al. Recovery of HgCl 2 Using Polyaminated Highly Porous Chitosan Beads-Effect of Salt and Acid [J]. J. Chem. Eng. Jpn., 1998, 31(1) : 1-5.
[8] 王志华, 王书俊, 黄毓礼. 壳聚糖絮凝有机废水机理的研究[J]. 工业水处理, 2002, 20(2) : 28-29.
[9] Li Dabang. Fractal geometry of particle aggregates generated in wa-ter and wastewater treatment process[J]. Environmental Science and Technology, 1989, 11: 1 385-1 390.
[10] Ganjidoust H. Effect of synthetic and natural coagulant on lignin removal from pulp and paper wastewater[J]. Wat. Sci. Tech., 1997, 35(2-3): 291-296.
/
〈 |
|
〉 |