UASB-A/O耦合工艺处理退浆印染废水中试研究

doi:10.11894/1005-829x.2018.38(11).052

工业水处理 ›› 2018, Vol. 38 ›› Issue (11): 52-56. doi: 10.11894/1005-829x.2018.38(11).052

UASB-A/O耦合工艺处理退浆印染废水中试研究

许明^1,2, 李超^1,3, 袁安德⁴, 白永刚^1,2, 涂勇^1,2, 李明³

1. 江苏省环境工程重点实验室, 江苏南京 210036;
2. 江苏省环境科学研究院, 江苏南京 210036;
3. 河海大学环境学院, 江苏南京 210019;
4. 淮安市洪泽区岔河镇农业技术服务站, 江苏淮安 223100

收稿日期:2018-08-30 出版日期:2018-11-20 发布日期:2018-11-16
通讯作者: 李超,副教授,博士。E-mail:lichao0609@163.com。 E-mail:lichao0609@163.com
作者简介:许明(1982-),博士,高工。E-mail:yexumingbai@163.com。
基金资助:
江苏省环境工程重点实验室科研开放基金（KF2017001）；江苏省第十四批“六大人才高峰”高层次人才项目（JNHB-086）；南京市2017年度科技发展计划（201716004）

Pilot-scale research on the treatment of desizing printing and dyeing wastewater by UASB-A/O coupling process

Xu Ming^1,2, Li Chao^1,3, Yuan Ande⁴, Bai Yonggang^1,2, Tu Yong^1,2, Li Ming³

1. Jiangsu Provincial Key Laboratory of Environmental Engineering, Nanjing 210036, China;
2. Jiangsu Provincial Academy of Environmental Science, Nanjing 210036, China;
3. School of Environment, Hohai University, Nanjing 210019, China;
4. Agricultural Technology Service Station of Chahe Town, Huaian 223100, China

Received:2018-08-30 Online:2018-11-20 Published:2018-11-16

摘要/Abstract

摘要： 高浓度聚乙烯醇（PVA）退浆印染废水中含大量难降解有机物，可生化性差，采用UASB-A/O耦合工艺处理该类废水。试验结果表明，UASB-A/O耦合工艺能够有效处理高浓度PVA印染废水，处理后的出水达到《纺织染整工业水污染排放标准》（GB 4287—2012）要求，PVA的降解率高达95%。GC/MS分析表明，该耦合工艺能够有效降解PVA退浆印染废水中的大分子有机物。

关键词: UASB-A/O, 退浆印染废水, PVA

Abstract: Highly concentration polyvinyl alcohol(PVA) desizing printing and dyeing wastewater contains a large number of refractory organic substances and its biodegradability is rather low. The UASB-A/O coupling process has been used for treating this kind of wastewater. The experimental results show that the UASB-A/O coupling process can effectively treat the highly concentrated PVA printing and dyeing wastewater. The treated effluent meets the requirements for the Discharge Standard for Water Pollution for Textile Dyeing and Finishing Industries(GB 4287-2012). The degradation rate of PVA is as high as 95%. GC/MS analysis shows that the coupling process could effectively degrade the large molecular organic substances in PVA desizing printing and dyeing wastewater.

Key words: UASB-A/O, desizing printing and dyeing wasterwater, PVA

中图分类号:

X703.1

许明, 李超, 袁安德, 白永刚, 涂勇, 李明. UASB-A/O耦合工艺处理退浆印染废水中试研究[J]. 工业水处理, 2018, 38(11): 52-56.

Xu Ming, Li Chao, Yuan Ande, Bai Yonggang, Tu Yong, Li Ming. Pilot-scale research on the treatment of desizing printing and dyeing wastewater by UASB-A/O coupling process[J]. INDUSTRIAL WATER TREATMENT, 2018, 38(11): 52-56.

https://www.iwt.cn/CN/Y2018/V38/I11/52

参考文献

[1] 马永喜,王娟丽,李一. 纺织工业废水处理模式改进研究[J]. 丝绸,2017,54(4):37-42.
[2] 温沁雪,王进,郑明明,等. 印染废水深度处理技术的研究进展及发展趋势[J]. 化工环保,2015,35(4):363-369.
[3] 黄阳阳,夏云,孙晨晓. 纺织浆料发展综述[J]. 丝绸,2017,54(7):29-37.
[4] Yu Hanqing,Gu G,Song L. Degradation of polyvinyl alcohol in sequencing batch reactors[J]. Environmental Technology Letters, 1996,17(11):1261-1267.
[5] Zou Haiming,Wang Yan. Azo dyes wastewater treatment and simul-taneous electricity generation in a novel process of electrolysis cell combined with microbial fuel cell[J]. Bioresource Technology,2017, 235:167-175.
[6] Wang Hongcheng,Cui Dan,Yang Lihui,et al. Increasing the bio-electrochemical system performance in azo dye wastewater treatment:Reduced electrode spacing for improved hydrodynamics[J]. Bioresource Technology,2017,245(Part A):962-969.
[7] Paz A,Carballo J,Pérez M J,et al. Biological treatment of model dyes and textile wastewaters[J]. Chemosphere,2017,181:168-177.
[8] 裴义山,杨永哲,王磊,等. MBR处理聚乙烯醇废水的试验研究[J]. 给水排水,2004,30(11):53-56.
[9] 徐一飞,沈阳,朱少华,等. 缺氧/好氧处理高浓度PVA退浆废水[J]. 中国给水排水,2004,20(8):79-81.
[10] Is k M,Sponza D T. Anaerobic/aerobic treatment of a simulated textile wastewater[J]. Separation & Purification Technology,2008,60(1):64-72.
[11] 谢新各,程丽华,王存峰. 济宁污水处理厂升级改造中试研究[J]. 青岛理工大学学报,2012,33(1):80-84.
[12] 周密. UV/Fenton法处理含PVA废水的试验研究[D]. 长沙:长沙理工大学,2013.
[13] 薄国柱. UBF厌氧复合反应器处理高浓度退浆废水试验研究[D]. 南京:河海大学,2005.
[14] 梅荣武,徐华正,沈浙萍. 含PVA印染废水处理提标改造工程实例研究[J]. 环境科学与管理,2016,41(3):85-88.
[15] Li Fang,Huang Jiahua,Xia Qin,et al. Direct contact membrane distillation for the treatment of industrial dyeing wastewater and characteristic pollutants[J]. Separation and Purification Technology, 2018,195:83-91.

选择文件类型/文献管理软件名称

选择包含的内容

UASB-A/O耦合工艺处理退浆印染废水中试研究

Pilot-scale research on the treatment of desizing printing and dyeing wastewater by UASB-A/O coupling process

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价

[1]	刘富华. Ag改性PVA/SrTiO₃/TiO₂光催化材料的制备及性能[J]. 工业水处理, 2022, 42(7): 125-132.
[2]	李功松, 陈小光, 汪彩华. 含PVA废水处理工艺探讨[J]. 工业水处理, 2019, 39(10): 20-25, 31.
[3]	辛红香, 张正和, 胡俊腾, 张绪俊, 李建军, 郑梅, 张勇, 姜安平. 蒙维科技PVA废水处理与回用工程设计[J]. 工业水处理, 2016, 36(10): 94-97.

模态框（Modal）标题

选择文件类型/文献管理软件名称

选择包含的内容

UASB-A/O耦合工艺处理退浆印染废水中试研究

Pilot-scale research on the treatment of desizing printing and dyeing wastewater by UASB-A/O coupling process

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

编辑推荐

Metrics

本文评价