Experiment study on ozone catalytic oxidation coupled with MBR for advanced treatment of landfill leachate

doi:10.11894/iwt.2019-0267

Industrial Water Treatment ›› 2020, Vol. 40 ›› Issue (3): 78-80, 84. doi: 10.11894/iwt.2019-0267

• Research and Experiment • Previous Articles Next Articles

Experiment study on ozone catalytic oxidation coupled with MBR for advanced treatment of landfill leachate

Xiaohui Wu¹(),Yutang Xiao^1,*(),Linquan Sun²,Yanfang Chen²,Aichun Miao²,Guanping Wang³,Wei Shi³

1. School of Environment, South China Normal University, Guangzhou 510006, China
2. Shenzhen Changlong Technology Co., Ltd., Shenzhen 518117, China
3. Everbright Water(Shenzhen) Co., Ltd., Shenzhen 518000, China

Received:2019-12-23 Online:2020-03-20 Published:2020-03-20
Contact: Yutang Xiao E-mail:768288990@qq.com;1712208542@qq.com
Supported by:
深圳市战略新兴产业发展专项资金(JSGG20170823153043998)

臭氧催化氧化耦合MBR深度处理垃圾渗滤液试验

吴晓慧¹(),肖羽堂^1,*(),孙临泉²,陈艳芳²,缪爱纯²,王冠平³,石伟³

1. 华南师范大学环境学院, 广东广州 510006
2. 深圳长隆科技有限公司, 广东深圳 518117
3. 光大水务(深圳)有限公司, 广东深圳 518000

通讯作者: 肖羽堂 E-mail:768288990@qq.com;1712208542@qq.com
作者简介:吴晓慧(1993—),硕士。E-mail:768288990@qq.com
基金资助:
深圳市战略新兴产业发展专项资金(JSGG20170823153043998)

Abstract

Abstract:

The ozone catalytic oxidation coupled with MBR process was used for advanced treatment of landfill leachate, which was pretreated by MBR. The effects of different processes on COD removal rate of landfill leachate was investigated using Co-Mn-Coal as the catalyst. The pre-oxidation could not only effectively remove COD, but also improve biodegradability. The MBR process could make the COD of biochemical effluent meet Standard for Pollution Control on the Landfill Site of Municipal Solid Waste(GB 16889-2008). Ozone catalytic oxidation and MBR process showed good synergy. After the advanced oxidation, the final effluent COD could reach Grade B of Discharge Standard of Pollutants for Municipal Wastewater Treatment Plant(GB 18918-2002).

Key words: landfill leachate, advanced treatment, ozone catalytic oxidation, coupling process

摘要：

采用臭氧催化氧化耦合MBR工艺对生化后的垃圾渗滤液进行深度处理，以钴锰煤粉作为催化剂，考察了各部分工艺对废水COD的去除效果。臭氧催化预氧化不仅有效地去除了COD，也提高了废水的可生化性，经MBR工艺处理后废水COD达到《生活垃圾填埋场污染控制标准》（GB 16889—2008）要求，二者有良好的协同性。再经臭氧催化深度氧化，最终出水COD能达到《城镇污水处理厂污染物排放标准》（GB 18918—2002）一级B标准。

关键词: 垃圾渗滤液, 深度处理, 臭氧催化氧化, 耦合工艺

CLC Number:

X703.1

Xiaohui Wu,Yutang Xiao,Linquan Sun,Yanfang Chen,Aichun Miao,Guanping Wang,Wei Shi. Experiment study on ozone catalytic oxidation coupled with MBR for advanced treatment of landfill leachate[J]. Industrial Water Treatment, 2020, 40(3): 78-80, 84.

吴晓慧,肖羽堂,孙临泉,陈艳芳,缪爱纯,王冠平,石伟. 臭氧催化氧化耦合MBR深度处理垃圾渗滤液试验[J]. 工业水处理, 2020, 40(3): 78-80, 84.

/ / Recommend / Download Citations

URL: https://www.iwt.cn/EN/10.11894/iwt.2019-0267

https://www.iwt.cn/EN/Y2020/V40/I3/78

Figures/Tables 5

References 11

1	王德芳, 高贤彪, 项娟, 等. 3种生活垃圾处置方式的特点解析及评价方法研究展望[J]. 天津农业科学, 2018, 24 (10): 73- 75. doi: 10.3969/j.issn.1006-6500.2018.10.018
2	Sri Shalini S , Joseph K . Nitrogen management in landfill leachate:Application of SHARON, ANAMMOX and combined SHARON-ANAMMOX process[J]. Waste Management, 2012, 32 (12): 2385- 2400. doi: 10.1016/j.wasman.2012.06.006 URL
3	熊建英, 郑正. 垃圾填埋场渗滤液溶解性有机质特性及其去除技术综述[J]. 环境化学, 2015, 34 (1): 44- 53. URL
4	王凯, 武道吉, 彭永臻, 等. 垃圾渗滤液处理工艺研究及应用现状浅析[J]. 北京工业大学学报, 2018, 44 (1): 1- 12. doi: 10.3969/j.issn.1671-0398.2018.01.002
5	胡君杰, 夏俊方, 方小琴, 等. 垃圾渗滤液短程硝化反硝化脱氮工艺的研究[J]. 工业水处理, 2016, 36 (5): 51- 54. URL
6	王晓艳, 买文宁, 郜白璐. 两级UASB反应器处理垃圾渗滤液的试验研究[J]. 工业水处理, 2018, 38 (9): 72- 75. URL
7	李章良, 郭海灵. 高级氧化技术处理垃圾渗滤液的研究现状与进展[J]. 环境工程, 2014, 32 (5): 30- 33. URL
8	吴晴, 刘金泉, 王凯, 等. 高级氧化技术在难降解工业废水中的研究进展[J]. 水处理技术, 2015, 41 (11): 25- 29. URL
9	邱家洲, 等. 臭氧高级氧化组合技术用于垃圾渗滤液深度处理[J]. 中国给水排水, 2013, 29 (18): 124- 126. URL
10	王凯, 武道吉, 陈举欣, 等. SBR处理渗滤液深度脱氮的影响因素研究[J]. 中国环境科学, 2016, 36 (11): 3287- 3294. doi: 10.3969/j.issn.1000-6923.2016.11.011
11	尹文俊, 周伟伟, 王凯, 等. 垃圾渗滤液物化与生化处理工艺技术现状[J]. 环境工程, 2018, 36 (2): 83- 87. URL

[1]	Jin LI, Lu QIU, Rui LIU, Jun LI, Hanyi LI, Bing YAN, Jiang HE, Xianjin LIANG, Biao YI. Evaluation model of landfill leachate treatment system design scheme [J]. Industrial Water Treatment, 2025, 45(3): 121-128.
[2]	Yang LI, Dongfang ZHANG, Jixian LIU, Haosheng DU, Xiaojie WANG. Case study on the comprehensive advanced treatment of PCB electroplating wastewater [J]. Industrial Water Treatment, 2025, 45(3): 212-218.
[3]	Quanfa ZHONG, Lin ZHONG, Guohui XU, Qinghai JIN, Jin YU, Fei XU, Di HE. Unravelling molecular transformation of dissolved organic matter in the full quantization treatment of landfill leachate concentrate [J]. Industrial Water Treatment, 2025, 45(2): 109-117.
[4]	Ziang CHEN, Yiting YANG, Qian CHI, Jingjing YANG, Guangsen XIA, Juhong ZHAN. Effect of electrocatalytic ozone coupled with bioactived carbon process on removal of carbamazepine and microbial community in wastewater [J]. Industrial Water Treatment, 2024, 44(9): 91-97.
[5]	Likun GU, Jianxin HAO, Jinwei YUE, Heming XU, Donghui CAO, Yichao LI, Zhaoxu PENG, Jianyun ZHANG. Sludge adaptability during start-up of anaerobic reactor for leachate from garbage power plant [J]. Industrial Water Treatment, 2024, 44(9): 75-84.
[6]	Zheng LIU, Long YANG, Zuoxu ZHOU, Lei ZHANG, Xunsheng JI. An advanced treatment project of wastewater from PA66 salt producted by butadiene process [J]. Industrial Water Treatment, 2024, 44(7): 185-189.
[7]	Yuhong ZHANG, Dunchao ZHANG, Xiulan SONG, Na HE. Advanced treatment of coking wastewater with peroxymonosulfate oxidation activated by base combined with SBBR [J]. Industrial Water Treatment, 2024, 44(6): 94-100.
[8]	Xufeng LI, Shaopo WANG, Yao ZHOU, Jing CHANG, Rongguang LI. Enhanced treatment technology for Yangtze River water in a water purification plant in Tianjin [J]. Industrial Water Treatment, 2024, 44(5): 132-140.
[9]	Qinqi FAN, Chun LIU, Situ MU, Jing ZHANG, Yankai GUO, Junjun MA. Operation performance of a pilot plant of microbubble ozonation and biological treatment for advanced treatment of chemical wastewater [J]. Industrial Water Treatment, 2024, 44(4): 120-126.
[10]	Zeyi LI, Changsheng LIAO, Yun CHAI, Qinghong WANG, Yali ZHAN, Chunmao CHEN, Fayuan CHEN. Characteristics of biochemical tail water from coking wastewater and current progress in advanced treatment technologies [J]. Industrial Water Treatment, 2024, 44(3): 10-23.
[11]	Xueliang WANG, Yongkui YANG. Engineering application of ozone catalytic oxidation in the treatment of monocrystalline silicon cutting fluid wastewater [J]. Industrial Water Treatment, 2024, 44(3): 195-198.
[12]	Lin HAN, Yongming CHENG, Dongmei WANG, Yajuan LI, Jie ZHANG. Problem diagnosis and analysis of advanced treatment system for reclaimed water in a power plant [J]. Industrial Water Treatment, 2024, 44(3): 206-210.
[13]	Hai CHEN, Senfei XU, Huanzheng ZHU, Chunyuan ZHANG, Tao ZHANG, Jieping LU, Shijun HE. Treatment of landfill leachate by using electron beam technology [J]. Industrial Water Treatment, 2024, 44(2): 166-171.
[14]	Ning AN, Yuying HAO, Shaowei HU, Peng CHEN, Fei WANG, Yong WANG, Fang LIU, Hanfei LI. Photocatalytic treatment of coking wastewater by cerium oxide loading with nitrogen-doping co-modified graphite carbon nitride [J]. Industrial Water Treatment, 2024, 44(12): 184-191.
[15]	Huixiang ZHANG, Xuemin ZHANG, Sanxiang SUN, Li LI. Small pilot study of ultra-high pressure reverse osmosis technology for treating landfill leachate in Northwest China [J]. Industrial Water Treatment, 2024, 44(12): 104-108.

Please choose a citation manager

Content to export