玻璃珠强化超声空化效应的研究及应用

doi:10.11894/1005-829x.2015.35(11).045

工业水处理 ›› 2015, Vol. 35 ›› Issue (11): 45-48. doi: 10.11894/1005-829x.2015.35(11).045

玻璃珠强化超声空化效应的研究及应用

田慧芳, 张光明, 赵鹤

中国人民大学环境学院, 北京 100872

收稿日期:2015-09-21 出版日期:2015-11-20 发布日期:2015-11-26
作者简介:田慧芳(1989-),硕士.电话:18813195418,E-mail:thf90527@foxmail.com.
基金资助:
中央高校基本科研业务费专项资金(14XLNQ02)

Study and application of enhancing effect of ultrasonic cavitation by adding glass balls

Tian Huifang, Zhang Guangming, Zhao He

School of Environment and Natural Resources, Renmin University of China, Beijing 100872, China

Received:2015-09-21 Online:2015-11-20 Published:2015-11-26
Contact: 10.11894/1005-829x.2015.35(11).045

摘要/Abstract

摘要：

研究了玻璃珠对超声空化效应的强化作用,探讨了玻璃珠粒径、剂量对超声辐照纯水产生H₂O₂的影响,研究了玻璃珠对超声氧化降解染料废水中亚甲基蓝的强化效果.结果表明,玻璃珠的加入能够强化超声空化作用.当玻璃珠粒径为0.120 mm、投加质量浓度为10 g/L时超声空化效果最好,H₂O₂的产量提高了1.8倍.在此条件下,超声氧化降解亚甲基蓝的去除率可达73.8%.

关键词: 超声空化, 玻璃珠, 过氧化氢, 亚甲基蓝

Abstract:

The enhancing effect of ultrasonic cavitation by adding glass balls has been studied. The influences of the granular size and dosage of glass balls on the yield of H₂O₂,which was produced from ultrasonic irradiation on pure water,are discussed,and the enhancing effect of glass balls on ultrasonic degradation of methylene blue contained in dyeing wastewater has been investigated. The results show that the addition of glass balls can enhance ultrasonic cavitation effect. The ultrasonic cavitation effect is the best,the yield of H₂O₂ increases 1.8 times,when the granular size of glass balls are 0.120 mm,and its mass concentration is 10 g/L. Under these conditions,the removing rate of methylene blue by ultrasonic oxidation degradation can reach 73.8%.

Key words: ultrasonic cavitation, glass balls, hydrogen peroxide, methylene blue

中图分类号:

X703.1

田慧芳, 张光明, 赵鹤. 玻璃珠强化超声空化效应的研究及应用[J]. 工业水处理, 2015, 35(11): 45-48.

Tian Huifang, Zhang Guangming, Zhao He. Study and application of enhancing effect of ultrasonic cavitation by adding glass balls[J]. INDUSTRIAL WATER TREATMENT, 2015, 35(11): 45-48.

https://www.iwt.cn/CN/Y2015/V35/I11/45

参考文献

[1] 冯若. 超声手册[M]. 南京:南京大学出版社,1999:78-88.
[2] 王建信. 水中有机污染物超声强化氧化技术研究进展[J]. 环境污染治理技术与设备,2003,4(4):66-68.
[3] Patil M N,Pandit A B. Cavitation:a novel technique for making stable nano-suspensions[J]. Ultrasonics Sonochemistry,2007,14(5):519-530.
[4] Rooze J,Rebrov E V,Schouten J C,et al. Dissolved gas and ultrasonic cavitation:a review[J]. Ultrasonics Sonochemistry,2013,20(1):1-11.
[5] Sivakumar M,Tatake P A,Pandit A B. Kinetic of p-nitrophenol degradation:effect of rection conditions and cavitational parameters for a multiple frequency system[J]. Chemical Engineering Journal,2002(85):327-338.
[6] Feng R,Zhao Y Y,Zhu C P,et al. Enhancement of ultrasonic cavitation yield by multi-frequency sonication[J]. Ultrasonics Sonochemisty,2002,9(5):231-236.
[7] Hou L,Zhang H,Wang L,et al. Ultrasound-enhanced magnetite catalytic ozonation of tetracycline in water[J]. Chemical Engineering Journal,2013(229):577-584.
[8] Marschall H B,Morch K A,Keller A P,et al. Cavitation inception by almost spherical solid particles in water[J]. Physics of Fluids,2003(15):545-553.
[9] Tuziuti T,Yasui K,IidaY,et al. Effect of particle addition on sonochemical reaction[J]. Ultrasonics,2004,42(1):597-601.
[10] Kim T Y,Lee Y H,Park K H,et al. A study of photocatalysis of TiO₂ coated onto chitosan beads and activated carbon[J]. Research on Chemical Intermediates,2005,31(4/5/6):343-358.
[11] Sakthivel S,Shankar M V,Palanichamy M,et al. Photocatalytic decomposition of leather dye:comparative study of TiO₂ supported on alumina and glass beads[J]. Journal of Photochemistry and Photobiology A:Chemistry,2002,148(1):153-159.
[12] Shen J M,Li X Y,Chen Z L,et al. Degradation of macromolecular tannic acid by O₃/H₂O₂[J]. Water Science and Technology,2008,57(12):2043-2050.
[13] Liu L,Yang Y,Liu P,et al. The influence of air content in water on ultrasonic cavitation field[J]. Ultrasonics sonochemistry,2014,21(2):566-571.
[14] Huang L B,Wu S J,Zhou F M. Several factors affecting sonochemical yield[J]. Technical Acoustics,2005(4):210-214.
[15] Petrier C,Lamy M F,Francony A,et al. Sonochemical degradation of phenol in dilute aqueous solutions:comparison of the reaction rates at 20 and 487 kHz[J]. The Journal of Physical Chemistry,1994,98(41):10514-10520.
[16] Suslick K S. Ultrasound:Its chemical,physical,and biological effects[M]. VCH,NewYork,1988:305-320.
[17] 葛建团,曲久辉,王国华. H₂O超声过程中H₂O₂生成动力学[J]. 环境化学,2004,23(2):141-144.
[18] 丁雷,王佳平,赵一先,等. 纯水体系超声空化产额研究[J]. 工业水处理,2010,30(3):34-37.
[19] Namguk H,Jong-Sung P,Yeomin Y. Sonochemical enhancement of hydrogen peroxide production by inert glass beads and TiO₂-coated glass beads in water[J]. Chemical Engineering Journal,2011(166):184-190.
[20] 古映莹,李丹. 碘量法和铈量法测定过氧化氢的研究[J]. 湖南理工学院学报:自然科学版,2005,18(3):56-58.
[21] Saliby E I,Erdei L,Kim J H,et al. Adsorption and photocatalytic degradation of methylene blue over hydrogen-titanate nanofibres produced by a peroxide method[J]. Water Research,2013,47(12):4115-4125.
[22] Xu R,Jiang R,Wang J,et al. A novel method treating organic wastewater:Air-bubble cavitation passing small glass balls[J]. Chemical Engineering Journal,2010,164(1):23-28.
[23] Henriksen H K,Ostergaard K. On the mechanism of breakup of large bubble in liquids and three-phase fluidized bed[J]. Chemical Engineering Science,1974,29(2):626-629.
[24] 李廷盛,尹其光. 超声化学[M]. 北京:科学出版社,1995:46-48.
[25] Tuziuti T,Yasui K,Sivakumar M,et al. Correlation between acoustic cavitation noise and yield enhancement of sonochemical reaction by particle addition[J]. The Journal of Physical Chemistry A,2005,109(21):4869-4872.
[26] Teo K C,Xu Y R,Yang C. Sonochemical degradation for toxic halogenated organic compounds[J]. Ultrasonics Sonochemistry,2001,8(3):241-246.
[27] Adewuyi Y G. Sonochemistry:environmental science and engineering applications[J]. Industrial & Engineering Chemistry Research,2001,40(22):4681-4715.
[28] Shimizu S N,Ogino C,Dadjour M F,et al. Sonocatalytic degradation of methylene blue with TiO₂ pellets in water[J]. Ultrasonics Sonochemistry,2007,14(2):184-190.
[29] Eren Z,Ince N H. Sonolytic and sonocatalytic degradation of azo dyes by low and high frequency ultrasound[J]. Journal of Hazardous Materials,2010,177:1019-1024.
[30] Wang H,Huang Y. Prussian-blue-modified iron oxide magnetic nanoparticles as effective peroxidase-like catalysts to degrade meethylene blue with H₂O₂[J]. Journal of Hazardous Materials,2011,191(1):163-169.

选择文件类型/文献管理软件名称

选择包含的内容

玻璃珠强化超声空化效应的研究及应用

Study and application of enhancing effect of ultrasonic cavitation by adding glass balls

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王庆元, 张彦平, 李一兵, 李芬. 农膜-秸秆生物质炭对亚甲基蓝的吸附性能[J]. 工业水处理, 2025, 45(3): 110-120.
[2]	韩雨璇, 倪志娇, 卢洪伟. 添加剂对DBD处理亚甲基蓝模拟废水的影响[J]. 工业水处理, 2025, 45(3): 165-174.
[3]	张拔群, 罗仙平, 唐学昆, 吴尧尧, 余嗣昊, 熊瑜婷. 天然矿物纤维水镁石活化过一硫酸盐降解亚甲基蓝[J]. 工业水处理, 2025, 45(2): 85-95.
[4]	陈越, 彭雪儿, 周琛阳, 李婧, 孟欣怡, 高丽丽. CuFeKao粒子电极三维非均相电Fenton体系降解亚甲基蓝[J]. 工业水处理, 2025, 45(2): 54-62.
[5]	黄年花, 黄思林, 陆红叶, 马璐, 凌绍明. 亚甲基蓝共振散射光谱法测定地下水中亚氯酸根[J]. 工业水处理, 2024, 44(6): 198-202.
[6]	白兵兵, 杨晨晔, 豆龙龙, 周瑞, 张洁, 汤颖. 负载型零价过渡金属在双氧化体系下降解高稳定油田污染物[J]. 工业水处理, 2024, 44(12): 123-130.
[7]	覃毅雪, 王盛, 张兵兵, 陈蔚洁, 安明泽, 杨照, 秦舒浩. 锌硫功能生物炭活化过二硫酸盐降解亚甲基蓝[J]. 工业水处理, 2024, 44(11): 82-92.
[8]	丁琨, 江娜, 孙红军, 李魁, 杨雯, 阮丽君, 胡昊. 厨余垃圾木质素改性处理亚甲基蓝废水性能研究[J]. 工业水处理, 2023, 43(8): 128-136.
[9]	高雅, 梁栋, 常欢, 何佩霖, 刘新. 中药通草渣对水中亚甲基蓝吸附效能与机理的研究[J]. 工业水处理, 2023, 43(4): 121-129.
[10]	杨鑫宇, 符爱东, 武向前, 沈国涛, 方翔, 赵俭波. 改性生物质炭负载铁类Fenton体系降解亚甲基蓝研究[J]. 工业水处理, 2023, 43(4): 98-104.
[11]	陈佼, 李晓媛, 刘钰洁, 陆一新. 槟榔渣生物炭对水中亚甲基蓝的吸附特性及机制[J]. 工业水处理, 2023, 43(3): 55-63.
[12]	蔡成坤, 魏红福, 刘希阳, 王亚洲. 生物发酵前处理生物炭对亚甲基蓝的吸附研究[J]. 工业水处理, 2023, 43(3): 80-86.
[13]	陈宝宁, 丁春华, 方岩雄, 刘全兵. Ag₂O/WO₃-SiO₂气凝胶的制备及光催化性能研究[J]. 工业水处理, 2023, 43(2): 136-141.
[14]	杨赟, 赵莹鑫, 王玉龙, 杨水金. 镍掺杂MIL-53（Fe）吸附亚甲基蓝性能研究[J]. 工业水处理, 2023, 43(11): 154-160.
[15]	王尔珍, 田飞, 方玉峰, 孙爽, 李莹, 于熙洋, 乔健鑫, 宋文平. 超声-臭氧快速降解油田含聚洗井液的试验研究[J]. 工业水处理, 2023, 43(10): 163-167.

模态框（Modal）标题

选择文件类型/文献管理软件名称

选择包含的内容

玻璃珠强化超声空化效应的研究及应用

Study and application of enhancing effect of ultrasonic cavitation by adding glass balls

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价