Study on the treatment of wastewater from rice wine production by ABR-CSTR combined process

doi:10.11894/1005-829x.2016.36(3).043

INDUSTRIAL WATER TREATMENT ›› 2016, Vol. 36 ›› Issue (3): 43-46. doi: 10.11894/1005-829x.2016.36(3).043

Previous Articles Next Articles

Study on the treatment of wastewater from rice wine production by ABR-CSTR combined process

Fu Yujie^1,2, Wu Peng^1,2, Xu Lezhong^1,2, Shen Yaoliang^1,2,3

1. School of Environmental Science and Engineering, Suzhou University of Science and Technology, Suzhou 215009, China;
2. Jiangsu Collaborative Innovation Center of Technology and Material of Water Treatment, Suzhou 215009, China;
3. Jiangsu Key Laboratory of Environmental Science and Engineering, Suzhou University of Science and Technology, Suzhou 215009, China

Received:2016-01-19 Online:2016-03-20 Published:2016-03-29

ABR-CSTR组合工艺处理黄酒生产废水研究

付玉洁^1,2, 吴鹏^1,2, 徐乐中^1,2, 沈耀良^1,2,3

1. 苏州科技学院环境科学与工程学院, 江苏苏州 215009;
2. 江苏省水处理技术与材料协同创新中心, 江苏苏州 215009;
3. 苏州科技学院江苏省环境科学与工程重点实验室, 江苏苏州 215009

通讯作者: 徐乐中,E-mail:kgre505@163.com。 E-mail:kgre505@163.com
作者简介:付玉洁(1990-),硕士。电话:15250982057,E-mail:fufu_yujie@163.com。
基金资助:
江苏省高校自然科学研究重大项目(12KJA610002);苏州市环保科技项目(B20130502)

Abstract

Abstract:

The research on the treatment of wastewater from rice wine production by the combined process, ABR-CSTR, has been accomplished. The results show that the key of starting up the ABR-CSTR process successfully is by means of using low load start-up and then increasing the volume load gradually. When the operation temperature is(30±2) ℃, the COD volume load increases from 0.3 kg/(m³·d) to 4.0 kg/(m³·d). The start-up is successful in 100 d.The total removing rate of the system stays constant at 95%-98%. The average effluent concentration of NH₄⁺-N and TN are 0.57 mg/L and 20.4 mg/L, respectively. The results indicate that ABR-CSTR process can effectively treat the wastewater from rice wine production.

Key words: wastewater from rice wine production, anaerobic baffle-plate reactor, completely mixed reactor, start-up

摘要：

采用ABR-CSTR组合工艺对黄酒生产废水处理进行了研究。结果表明,采用低负荷启动并逐步提高容积负荷是ABR-CSTR组合工艺成功启动的关键,在温度为(30±2)℃时,COD容积负荷从0.3 kg/(m³·d)增至4.0 kg/(m³·d),历时100 d启动成功。系统总去除率保持在95%~98%,出水平均氨氮、总氮分别为0.57、20.4 mg/L,表明ABR-CSTR组合工艺能有效处理黄酒生产废水。

关键词: 黄酒生产废水, 厌氧折流板反应器, 完全混合式反应器, 启动

CLC Number:

X703.1

Fu Yujie, Wu Peng, Xu Lezhong, Shen Yaoliang. Study on the treatment of wastewater from rice wine production by ABR-CSTR combined process[J]. INDUSTRIAL WATER TREATMENT, 2016, 36(3): 43-46.

付玉洁, 吴鹏, 徐乐中, 沈耀良. ABR-CSTR组合工艺处理黄酒生产废水研究[J]. 工业水处理, 2016, 36(3): 43-46.

/ / Recommend / Download Citations

URL: https://www.iwt.cn/EN/10.11894/1005-829x.2016.36(3).043

https://www.iwt.cn/EN/Y2016/V36/I3/43

References

[1] 刘海亚,朱定松. 黄酒工业废水处理技术[J]. 工业水处理,2005, 25(2):67-68.
[2] 王琼艳. 绍兴黄酒产污系数调查研究[J]. 环境污染与防治,1995, 17(2):37-38.
[3] 孙建国,邵巍. UASB-AB工艺处理黄酒废水[J]. 给水排水,2006, 32(12):61-63.
[4] 王明明,宋波. 酿酒厂高浓废水及其治理措施[J]. 科技风,2010(24):267-269.
[5] Ince B K,Ince O,Anderson G K,et al. Assessment of biogas use as an energy source from anaerobic digestion of brewery wastewater[J]. Water,Air,and Soil Pollution,2001,126(3):239-251.
[6] Ahn Y H,Min K S,Speece R E. Full scale UASB reactor performance in the brewery industry[J]. Environmental Technology,2001,22(4):463-476.
[7] 罗刚,谢丽,周琪,等. 高温厌氧CSTR反应器处理木薯酒精废水研究[J]. 中国给水排水,2008,24(9):13-16.
[8] 林长松,徐龙飞,谈林友. 啤酒废水常温厌氧消化启动及运行实验[J]. 环境工程学报,2013,7(4):1389-1393.
[9] 黄武. 水解酸化-UASB处理高浓度酿酒废水[J]. 环境工程,2001, 19(5):50-51.
[10] 严凯,姜涛,宋雅建,等. UASB-SBR组合工艺处理小麦酒精废水[J]. 工业水处理,2014,34(9):57-60.
[11] 张毅,步德新,潘勇伟. UASB-CASS-接触氧化工艺处理玉米酒精废水[J]. 环境工程,2005,23(5):10-12.
[12] 高雅玉,韩志勇,钱鞠,等. 厌氧-好氧工艺处理啤酒生产废水[J]. 水处理技术,2010,36(4):130-134.
[13] Zhu Gefu,Li Jianzheng,Liu Chaoxiang,et al. Simultaneous production of biohydrogen and methane from soybean protein processing wastewater treatment using anaerobic baffled reactor(ABR)[J]. Desalination and Water Treatment,2015,53(10):2675-2685.
[14] 杨建,聂一波,李东伟. ABR反应器处理有机废水的运行特性研究[J]. 水处理技术,2009,35(1):42-45.
[15] 昌盛,李建政,刘枫. 厌氧折流板反应器处理大豆蛋白废水的运行特性[J]. 中国沼气,2008,26(2):10-13.
[16] 张雯,邓风,何超群. CSTR反应器好氧颗粒污泥脱氮影响因素研究[J]. 水处理技术,2011,37(1):116-120.
[17] 李媛,沈耀良,孙立柱. 采用CSTR反应器培养好氧颗粒污泥的研究[J]. 中国给水排水,2008,24(5):10-13.
[18] 林英姿,王爽,于炳慧,等. ABR反应器的两种快速启动方法对比[J]. 环境工程学报,2009,3(4):669-672.
[19] 范荣桂,李贤,高海娟,等. 笼状填料式ABR反应器处理啤酒废水启动试验[J]. 中国给水排水,2013,29(9):113-116.
[20] 国家环保总局. 水和废水监测分析方法[M]. 4版. 北京:中国环境科学出版社,2002:200-284.
[21] 沈耀良,王宝贞. 废水生物处理新技术[M]. 北京:中国环境科学出版社,2006:47-70.
[22] 贺延龄. 废水的厌氧生物处理[M]. 北京:中国轻工业出版社,1998:47-50.
[23] 徐金兰,王志盈,刘可,等. ABR系统中酸解过程的污泥特性及分析[J]. 环境污染治理技术与设备,2004,5(2):46-51.
[24] 郑平,徐向阳,胡宝兰. 新型生物脱氮理论与技术[M]. 北京:科学出版社,2004:35-46.
[25] 侯红娟,王洪洋,周琪. 进水COD及C/N值对脱氮效果的影响[J].中国给水排水,2005,21(12):19-23.

Please choose a citation manager

Content to export

Study on the treatment of wastewater from rice wine production by ABR-CSTR combined process

ABR-CSTR组合工艺处理黄酒生产废水研究

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Ning LIU, Yang HE, Depeng WANG, Qing YANG, Chenchen QIU, Qi LUO, Kailong HUANG, Xuxiang ZHANG. Expression characteristics of nitrogen metabolism functional genes in rapid start-up process of partial denitrification and anammox process [J]. Industrial Water Treatment, 2022, 42(4): 57-64.
[2]	Xinlei Zhao,Xue Fu,Peiyue Mao,Min'an Zhang,Xinbo Wu,Juan Ma,Yongzhi Chen. Performance of denitrifying-nitrogen and phosphorus-removal of A²/O-BAF two-sludge system during secondary start-up [J]. Industrial Water Treatment, 2021, 41(9): 81-85, 91.
[3]	Guanheng Li,Yujia Wang,Chao Shi,Jinming Zhang. Research progress of Feammox's processing characteristics and control strategies [J]. Industrial Water Treatment, 2021, 41(8): 34-40.
[4]	Xiaojun Meng,Nannan Guo,Zhigui Huang. Regulatory strategies of limiting factors for Anammox process application [J]. Industrial Water Treatment, 2021, 41(7): 56-63.
[5]	Na WANG,Jungang ZHANG,Xiaoran YAO,Ye DING. Initial rain treatment using moving bed biofilm reactor in coastal industrial clusters [J]. Industrial Water Treatment, 2021, 41(11): 61-64.
[6]	Xian Wang,Tao Wang,Shuhang Wang,Hu Li,Jingwen Liu. Storage and activation of Anaerobic ammonium oxidation sludge under room temperature conditions [J]. Industrial Water Treatment, 2020, 40(4): 44-48.
[7]	Luo Zheng, Wang Tao, Wang Shuhang, Wang Xian, Huang Zhuoshi, Zhang Mingyang. Start-up of a CANON fixed-bed reactor by inoculating mixed sludge [J]. Industrial Water Treatment, 2019, 39(9): 33-36.
[8]	Fuqin Li, Xing Wen, Guifeng Zhao, Yi Cui. Start-up of series ASBR in the treatment of high-concentration organic wastewater from nitrocellulose [J]. Industrial Water Treatment, 2019, 39(10): 54-58.
[9]	Wang Xiaoyan, Mai Wenning, Gao bailu. Experimental research on the treatment of landfill leachate by the two-stage UASB reactors [J]. INDUSTRIAL WATER TREATMENT, 2018, 38(9): 72-75.
[10]	Chi Chunrong, Chen Gang, Dong Shanyan, Liu Zuwen, Wan Liqian, Chen Qichun. Research on rapid start-up of UniTank process under low-carbon source sewage condition [J]. INDUSTRIAL WATER TREATMENT, 2018, 38(4): 21-24,36.
[11]	Zhang Diandian, Wang Tao, Wang Shuhang, Huang Chao, Dong Boying, Ma Jianghong. Study on the start-up and operation performances of Anammox process by the fixed bed reactor with mixed fillings [J]. INDUSTRIAL WATER TREATMENT, 2017, 37(6): 52-56.
[12]	Zhang Yonghui, Peng Yongzhen, Zeng Liyun, Hu Shuchao, Cui Peng, Ma Juan, Chen Yongzhi. Quick start-up of low-substrate Anammox ASBR reactor at normal temperature [J]. INDUSTRIAL WATER TREATMENT, 2017, 37(2): 43-47.
[13]	Zhang Sha, Wang Tao, Liu Pengxiao, Huang Chao, Peng Rui. Study on the start-up of OLAND process at room temperature [J]. INDUSTRIAL WATER TREATMENT, 2016, 36(12): 77-81.
[14]	Yang Liu, He Yanling. Experimental research on rapid start-up of the EGSB reactor used for the treatment of regenerated papermaking wastewater [J]. INDUSTRIAL WATER TREATMENT, 2015, 35(5): 45-47.
[15]	Wu Jinwei, Wang Chengwen, Yu Hai. Treatment of Fischer-Tropsch wastewater by expanded granular sludge bed(EGSB) reactor [J]. INDUSTRIAL WATER TREATMENT, 2015, 35(11): 56-59.

模态框（Modal）标题

Please choose a citation manager

Content to export

Study on the treatment of wastewater from rice wine production by ABR-CSTR combined process

ABR-CSTR组合工艺处理黄酒生产废水研究

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments