Preparation of wetting resisted GO composite membrane and its application in membrane distillation treatment of printing and dyeing wastewater

doi:10.19965/j.cnki.iwt.2022-0803

Abstract

Key words: graphene oxide, direct contact membrane distillation, dyeing wastewater, crosslinking, antiwetting

CLC Number:

Shiyan HUANG, Mengmeng LOU, Jingzi LI, Fang LI. Preparation of wetting resisted GO composite membrane and its application in membrane distillation treatment of printing and dyeing wastewater[J]. Industrial Water Treatment, 2023, 43(7): 169-176.

黄世燕, 娄蒙蒙, 李璟孜, 李方. 抗润湿GO复合膜的制备及其在印染废水膜蒸馏处理中的应用[J]. 工业水处理, 2023, 43(7): 169-176.

/ / Recommend / Download Citations

URL: https://www.iwt.cn/EN/10.19965/j.cnki.iwt.2022-0803

https://www.iwt.cn/EN/Y2023/V43/I7/169

Figures/Tables 8

Fig. 1 The FESEM images of top surface and crossing-section of membranes

Fig. 2 FT-IR（a），XRD（b），XPS（c）and Raman spectra（d） of membranes

Fig. 3 Zeta potentials of GO and PEI-GO nanosheets

Fig. 4 Contact angles of membranes

Fig. 5 Flux and salt rejection of membranes

Fig. 6 Membrane flux and permeate conductivities

Table 1 The results of dyeing wastewater membrane distillation

膜	原水COD_Cr/（mg·L^-1）	渗透液COD_Cr/（mg·L^-1）	COD_Cr截留率/%	原水色度/倍	渗透液色度/倍	色度去除率/%	原水电导率/（μS·cm^-1）	渗透液电导率/（μS·cm^-1）
PVDF膜	4 704.7	268.2	94.3	3 500	38.5	98.9	28 500	100.2
PVDF-GO膜	4 704.7	61.16	98.7	3 500	17.5	99.5	28 500	39.46
PVDF-GO/PEI膜	4 704.7	14.11	99.7	3 500	0	100	28 500	39.12

Fig. 7 The FESEM and contact angle images of contaminated membranes

References 21

1	刘宏，倪静，叶仕青. 锑对活性污泥去除印染废水COD和氨氮的影响［J］. 工业水处理，2022，42（7）：87-94.
	LIU Hong， NI Jing， YE Shiqing. Effect of antimony on the removal of COD and ammonia nitrogen from printing and dyeing wastewater by activated sludge［J］. Industrial Water Treatment，2022，42（7）：87-94.
2	DAMTIE M M， KIM B， WOO Y C，et al. Membrane distillation for industrial wastewater treatment：Studying the effects of membrane parameters on the wetting performance［J］. Chemosphere，2018，206：793-801. doi:10.1016/j.chemosphere.2018.05.070
3	AN A K， GUO Jiaxin， JEONG S，et al. High flux and antifouling properties of negatively charged membrane for dyeing wastewater treatment by membrane distillation［J］. Water Research，2016，103：362-371. doi:10.1016/j.watres.2016.07.060
4	FORTUNATO L， ELCIK H， BLANKERT B，et al. Textile dye wastewater treatment by direct contact membrane distillation：Membrane performance and detailed fouling analysis［J］. Journal of Membrane Science，2021，636：119552. doi:10.1016/j.memsci.2021.119552
5	TOLENTINO FILHO C M， DE SOUSA SILVA R， CAVALCANTI C D Á K，et al. Membrane distillation for the recovery textile wastewater：Influence of dye concentration［J］. Journal of Water Process Engineering，2022，46：102611. doi:10.1016/j.jwpe.2022.102611
6	贾艳萍，姜成，郭泽辉，等. 印染废水深度处理及回用研究进展［J］. 纺织学报，2017，38（8）：172-180. doi:10.13475/j.fzxb.20160603209
	JIA Yanping， JIANG Cheng， GUO Zehui，et al. Research progress on deep treatment and recycling of dye wastewater［J］. Journal of Textile Research，2017，38（8）：172-180. doi:10.13475/j.fzxb.20160603209
7	RAMLOW H， D’ÁVILA KRAMER CAVALCANTI C， MACHADO R A F，et al. Direct contact membrane distillation applied to colored reactive or disperse dye solutions［J］. Chemical Engineering & Technology，2019，42（5）：1045-1052. doi:10.1002/ceat.201800468
8	陈安稳，时翔云. 膜蒸馏过程的影响因素及其联合集成工艺研究进展［J］. 工业水处理，2013，33（2）：13-15. doi:10.3969/j.issn.1005-829X.2013.02.004
	CHEN Anwen， SHI Xiangyun. Research progress in the affecting factors on membrane distillation and its integrated technology［J］. Industrial Water Treatment，2013，33（2）：13-15. doi:10.3969/j.issn.1005-829X.2013.02.004
9	QIU Haoran， PENG Yuelian， GE Lei，et al. Pore channel surface modification for enhancing anti-fouling membrane distillation［J］. Applied Surface Science，2018，443：217-226. doi:10.1016/j.apsusc.2018.03.004
10	康赛，郑利兵，魏源送，等. 膜蒸馏在高氨氮废水处理与回用中的研究应用进展［J］. 工业水处理，2021，41（12）：15-21.
	KANG Sai， ZHENG Libing， WEI Yuansong，et al. Research and application progress of membrane distillation in high concentration ammonia nitrogen wastewaters treatment and recovery［J］. Industrial Water Treatment，2021，41（12）：15-21.
11	BOO C， LEE J， ELIMELECH M. Omniphobic polyvinylidene fluoride（PVDF） membrane for desalination of shale gas produced water by membrane distillation［J］. Environmental Science & Technology，2016，50（22）：12275-12282. doi:10.1021/acs.est.6b03882
12	任静，李剑锋，高瞻，等. 进水温度对膜蒸馏处理焦化废水效能的影响［J］. 工业用水与废水，2019，50（1）：13-18. doi:10.3969/j.issn.1009-2455.2019.01.004
	REN Jing， LI Jianfeng， GAO Zhan，et al. Effect of feedwater temperature on performance of coking wastewater treatment by membrane distillation［J］. Industrial Water ＆ Wastewater，2019，50（1）：13-18. doi:10.3969/j.issn.1009-2455.2019.01.004
13	谢松辰，文剑平，庞志广，等. 膜蒸馏脱盐中膜污染与膜润湿的研究进展［J］. 化工进展，2021，40（7）：3942-3956. doi:10.16085/j.issn.1000-6613.2020-1595
	XIE Songchen， WEN Jianping， PANG Zhiguang，et al. Research progress of membrane fouling and wetting in membrane distillation process for desalination［J］. Chemical Industry and Engineering Progress，2021，40（7）：3942-3956. doi:10.16085/j.issn.1000-6613.2020-1595
14	SU Pengcheng， WANG Fei， LI Zhanjun，et al. Graphene oxide membranes：Controlling their transport pathways［J］. Journal of Materials Chemistry A，2020，8（31）：15319-15340. doi:10.1039/d0ta02249g
15	张洁，韩宗臻，李成刚，等. 氧化石墨烯材料在污水处理中的应用研究进展［J］. 工业水处理，2020，40（8）：23-26. doi:10.11894/iwt.2019-0886
	ZHANG Jie， HAN Zongzhen， LI Chenggang，et al. Research progress in the application of graphene oxide materials in wastewater treatment［J］. Industrial Water Treatment，2020，40（8）：23-26. doi:10.11894/iwt.2019-0886
16	HUMMERS W S Jr， OFFEMAN R E. Preparation of graphitic oxide［J］. Journal of the American Chemical Society，1958，80（6）：1339. doi:10.1021/ja01539a017
17	XU Kai， FENG Bo， ZHOU Chen，et al. Synthesis of highly stable graphene oxide membranes on polydopamine functionalized supports for seawater desalination［J］. Chemical Engineering Science，2016，146：159-165. doi:10.1016/j.ces.2016.03.003
18	LI Songwei， YANG Peipei， LIU Xianhu，et al. Graphene oxide based dopamine mussel-like cross-linked polyethylene imine nanocomposite coating with enhanced hexavalent uranium adsorption［J］. Journal of Materials Chemistry A，2019，7（28）：16902-16911. doi:10.1039/c9ta04562g
19	LIANG Feng， LIU Dongxu， DONG Shurui，et al. Facile construction of polyzwitterion membrane via assembly of graphene oxide-based core-brush nanosheet for high-efficiency water permeation［J］. Journal of Membrane Science，2022，644：120150. doi:10.1016/j.memsci.2021.120150
20	CHEN Xiaoxiao， CHEN Baoliang. Direct observation，molecular structure，and location of oxidation debris on graphene oxide nanosheets［J］. Environmental Science & Technology，2016，50（16）：8568-8577. doi:10.1021/acs.est.6b01020
21	CHONG J Y， WANG B， LI K. Water transport through graphene oxide membranes：The roles of driving forces［J］. Chemical Communications，2018，54（20）：2554-2557. doi:10.1039/c7cc09120f

[1]	Gang XUE. Textile printing and dyeing wastewater treatment with low greenhouse gases emission [J]. Industrial Water Treatment, 2024, 44(7): 1-8.
[2]	Pengxiang ZHANG, Xubin CHEN, Jianguo TAN. Design and operation of centralized wastewater treatment facilities in printing and dyeing industry agglomeration improvement zone [J]. Industrial Water Treatment, 2024, 44(6): 209-214.
[3]	Fei SHI, Xue YANG, Jing SU, Hongbo WANG. Preparation of metal-organic framework polypropylene composites and degradation of printing and dyeing wastewater [J]. Industrial Water Treatment, 2024, 44(5): 101-110.
[4]	Tianyu LI, Feng ZHANG, Yanqing YANG, Zhehua DOU, Jianguo CUI. Sulfite-based simultaneous removal of Cr（Ⅵ） and Rhodamine B [J]. Industrial Water Treatment, 2024, 44(2): 157-165.
[5]	Fanke TONG, Tong GUAN, Shuangxi ZHOU, Wei WANG. Preparation of magnetic porous graphene for the adsorption of typical sulfonamides [J]. Industrial Water Treatment, 2024, 44(12): 109-117.
[6]	Yafeng LI, Siding XU, Chong GAO, Xiangyu FU. Treatment of reactive brilliant orange X-GN wastewater by three-dimensional electrode-electro-Fenton method [J]. Industrial Water Treatment, 2024, 44(1): 80-87.
[7]	Xiuzhen YANG, Shuangchan CHENG, Haolin ZHANG, Bin ZHOU, Baolin HOU. Adsorption of Sb in water with graphene oxide doped metal-organic framework [J]. Industrial Water Treatment, 2023, 43(9): 72-83.
[8]	Weisheng LIU, Xiaopeng WANG, Geng WANG, Tong LIU, Yan ZHANG, Shoujian ZHANG. Application of double circulation anaerobic process in high concentration dyeing wastewater treatment [J]. Industrial Water Treatment, 2023, 43(7): 217-222.
[9]	Yang YANG, Qian MA, Zenghui LI, Xudong YUAN, Pingfang WEI, Jie DAI. Preparation and degradation performance of N-Mn-TiO₂/AC particle electrode [J]. Industrial Water Treatment, 2023, 43(11): 114-119.
[10]	Qing YANG, Zhu WANG, Xinyu XU, Kailong HUANG, Depeng WANG, Yilin ZUO, Xuxiang ZHANG. Identification, construction and evaluation of key functional flora for NP degradation in printing and dyeing wastewater based on MMI technology [J]. Industrial Water Treatment, 2023, 43(11): 15-26.
[11]	Haoyang ZHANG, Ming LI, Jun WANG. Preparation of PA/PET/PDA/PVDF composite nanofiltration membrane and its application in dyeing wastewater treatment [J]. Industrial Water Treatment, 2023, 43(10): 150-156.
[12]	Xiaoyan LIAN, Dongtian WANG, Yu ZHONG, Jie WEI. Research progress on the treatment of industrial antimony-containing wastewater by coagulation [J]. Industrial Water Treatment, 2023, 43(10): 53-62.
[13]	Yan’an CHEN, Bailong XU, Ping DU, Binbin LIU. Project case of reclaimed water reuse and RO concentrated water advanced treatment of printing and dyeing wastewater [J]. Industrial Water Treatment, 2023, 43(1): 157-162.
[14]	Jinghao HUANG, Ying YANG, Xiaoyan HE, Xiang BAI. Adsorption performance of pyridine-based carbon nanocages for cationic dyes [J]. Industrial Water Treatment, 2022, 42(9): 109-116.
[15]	Hong LIU, Jing NI, Shiqing YE. Effect of antimony on the removal of COD and ammonia nitrogen from printing and dyeing wastewater by activated sludge [J]. Industrial Water Treatment, 2022, 42(7): 87-94.

Please choose a citation manager

Content to export