工业水处理 ›› 2019, Vol. 39 ›› Issue (1): 78-81. doi: 10.11894/1005-829x.2019.39(1).078

• 试验研究 • 上一篇    下一篇

膜法联合树脂吸附处理焦化废水中试研究

孙彩玉1,2, 边喜龙2, 刘芳2, 李永峰3, 齐世华2,4, 刘仁涛2   

  1. 1. 黑龙江科技大学环境与化工学院, 黑龙江哈尔滨 150022;
    2. 黑龙江建筑职业技术学院市政与环境工程学系, 黑龙江哈尔滨 150025;
    3. 东北林业大学林学院, 黑龙江哈尔滨 150040;
    4. 哈尔滨工业大学环境学院, 黑龙江哈尔滨 150090
  • 收稿日期:2018-11-15 发布日期:2019-01-30
  • 作者简介:孙彩玉(1986-),博士,讲师。E-mail:suncaiyuscy@126.com。
  • 基金资助:
    寒区城乡建设可持续发展协同创新中心项目（hxtcx-2015-01）

Pilot study on coking wastewater treatment by combining membrane process and resin adsorption

Sun Caiyu1,2, Bian Xilong2, Liu Fang2, Li Yongfeng3, Qi Shihua2,4, Liu Rentao2   

  1. 1. College of Environment and Chemical Engineering, Heilongjiang University of Science and Technology, Harbin 150022, China;
    2. Department of Municipal and Environmental Engineering, Heilongjiang Institute of Construction Technology, Harbin 150025, China;
    3. School of Forestry, Northeast Forestry University, Harbin 150040, China;
    4. School of Environment, Harbin Institute of Technology, Harbin 150090, China
  • Received:2018-11-15 Published:2019-01-30

RichHTML

PDF (Mobile)

4

摘要： 采用膜法联合树脂吸附组合为主体单元，通过建立高效澄清软化池+多介质过滤器+超滤+树脂吸附器+反渗透组合工艺对焦化废水深度处理回用进行120 d的现场中试试验。运行结果表明，在满足系统整体回收率为75%的前提下，系统产水各项指标均优于《污水再生利用工程设计规范》（GB 50335-2002）中循环冷却水补水水质，并能安全稳定运行。

关键词: 焦化废水, 膜法, 树脂吸附

Abstract: Using the combination of membrane process with resin adsorption as the main unit,a 120 d spot pilot scale test on the advanced treatment and reuse of coking wastewater has been implemented by establishing the combined process,high-efficient clarifying and softening pool+multi-media filter+ultrafiltration device+resin absorber+reverse osmosis. The running results show that on the premise of meeting the requirements of the system recovery rate of 75%, every index of the system produced water is superior to the water quality of make-up water for circulating cooling water,specified in the Design Criterion of Wastewater Reclaimation and Reuse Project(GB 50335-2002),and pledging to operate safely and stably,too.

Key words: coking wastewater, membrane process, resin adsorption

中图分类号: 

  • 主管/主办：中海油天津化工研究设计院有限公司
    出版单位：《工业水处理》编辑部
    ISSN　1005-829X
    CN　12-1087/TQ
  • 网站版权所有 © 2022《工业水处理》编辑部
    本系统由北京玛格泰克科技发展有限公司设计开发
    技术支持：support@magtech.com.cn
    违法和不良信息举报电话: 022-26689199
津ICP备05000975号-3 津公网安备 12010602120337号 网站版权所有 ©《工业水处理》编辑部