PAFC的制备及其在酸性红73废水处理中的应用

doi:10.11894/1005-829x.2014.34(11).044

工业水处理 ›› 2014, Vol. 34 ›› Issue (11): 44-47. doi: 10.11894/1005-829x.2014.34(11).044

PAFC的制备及其在酸性红73废水处理中的应用

卢志刚, 汤兵, 张姿, 付丰连, 杨慧文, 邢增孟

广东工业大学环境科学与工程学院, 广东广州 510006

收稿日期:2014-09-07 出版日期:2014-11-20 发布日期:2014-12-11
作者简介:卢志刚(1987-), 硕士.电话:18924258265, E-mail:1161794161@qq.com.
基金资助:
广州市科技攻关项目(2011J430069)

Preparation of polymeric aluminum ferric chloride flocculants and its application to the treatment of wastewater containing acid red 73

Lu Zhigang, Tang Bing, Zhang Zi, Fu Fenglian, Yang Huiwen, Xing Zengmeng

School of Environmental Science and Engineering, Guangdong University of Technology, Guangzhou 510006, China

Received:2014-09-07 Online:2014-11-20 Published:2014-12-11

摘要/Abstract

摘要：

以钢铁镀件前处理产生的酸洗废液和工业废铝为原料,采用氧化聚合法制备聚合氯化铝铁(PAFC)絮凝剂,并用PAFC处理低浓度的酸性红73,考察各因素对去除效果的影响.实验结果表明:在最佳条件下,PAFC处理10 mg/L的酸性红73的去除率高于85%,处理效果优于市售PAC,但与市售PAFC相当;铝铁比为9:1的PAFC处理5~20 mg/L的酸性红73,其上清液出水色度均达到了《纺织染整工业水污染物排放标准》(GB 4287-2012)中的特别排放限值要求;达到了以废治废的目的.

关键词: 酸洗废液, 工业废铝, 聚合氯化铝铁, 絮凝剂, 酸性红73

Abstract:

Polymeric aluminum ferric chloride flocculant(PAFC) has been prepared by oxidation-polymarization method,using the spent pickling liquors produced from the pretreatment of plated steel and industrial scrap aluminum as raw materials,and has been used for treating the wastewater containing acid red 73 with low concentration. The effects of various factors on the removing effectiveness are investigated. The results show that,under the optimal conditions,the removing rate of 10% of acid red 73 treated by PAFC is higher than 85%. The treatment effectiveness of the produced PAFC is superior to that of the commercial PAC,but rather the same as that of the commercial PAFC. When PAFC with an Al/Fe ratio of 9:1 is used for treating the wastewater containing acid red 73 from 5 mg/L to 20 mg/L,the supernatant effluent chroma could meet the requirements for the special discharge limit value of the Standard of Water Pollutants in Dyeing and Finishing of Textile Industry(GB 4287-2012),reaching the target of treating the wastes with wastes.

Key words: spent pickling liquor, scrap aluminum, polymeric aluminum ferric chloride, flocculant, acid red 73

中图分类号:

TQ314.253

卢志刚, 汤兵, 张姿, 付丰连, 杨慧文, 邢增孟. PAFC的制备及其在酸性红73废水处理中的应用[J]. 工业水处理, 2014, 34(11): 44-47.

Lu Zhigang, Tang Bing, Zhang Zi, Fu Fenglian, Yang Huiwen, Xing Zengmeng. Preparation of polymeric aluminum ferric chloride flocculants and its application to the treatment of wastewater containing acid red 73[J]. INDUSTRIAL WATER TREATMENT, 2014, 34(11): 44-47.

https://www.iwt.cn/CN/Y2014/V34/I11/44

参考文献

[1] Tang Bing,Yuan Liangjun,Shi Taihong,et al. Preparation of nano-sized magnetic particles from spent pickling liquors by ultrasonic-assisted chemical co-precipitation[J]. Journal of Hazardous Materials,2009,163(2/3):1173-1178.
[2] 肖娟宜,丁德才,王权永,等. 利用钢铁盐酸酸洗废液在填料塔中制备FeCl₃[J]. 化工环保,2013,33(1):59-62.
[3] Yang Shiying,Wang Ping,Yang Xin,et al. Degradation efficiencies of azo dye Acid Orange 7 by the interaction of heat,UV and anions with common oxidants: Persulfate,peroxymonosulfate and hydrogen per-oxide[J]. Journal of Hazardous Materials,2010,179(1/2/3):552-558.
[4] Wang Qingxiang,Gao Feng,Yuan Xianlong,et al. Electrochemicalstudies on the binding of a carcinogenic anthraquinone dye,Purpurin(C. I. 58 205) with DNA[J]. Dyes and Pigments,2010,84(3):213-217.
[5] Chequer F M,Angeli J P,Ferraz E R,et al. The azo dyes Disperse Red 1 and Disperse Orange 1 increase the micronuclei frequencies in human lymphocytes and in HepG2 cells[J]. Mutation Research,2009,676(1/2):83-86.
[6] 张毅,王伟,朱伟,等. 复合混凝剂处理模拟酸性大红染料废水的研究[J]. 安全与环境学报,2007,7(3):40-43.
[7] 温元凯,邵俊. 离子极化导论[M]. 合肥:安徽教育出版社,1985:94.
[8] 汤兵,朱又春. 氧化还原-络合滴定法连续测定Fe³⁺、Fe²⁺、Zn²⁺[J]. 中国给水排水,2001,17(4):59-61.
[9] Fu Fenglian,Wang Qi,Tang Bing. Effective degradation of C. I. AcidRed 73 by advanced Fenton process[J]. Journal of Hazardous Materials,2010,174(1/2/3):17-22.
[10] 章兴华,尹浩,周丽芸. 聚合氯化铝铁配位水含量与其稳定性关系的研究[J]. 四川大学学报:工程科学版,2001,33(2):60-62.
[11] 谢磊,胡勇有,程建华. 复合铝絮凝剂的制备及其脱色性能研究[J]. 工业水处理,2007,27(10): 57-59.
[12] Chen Ting,Gao Baoyu,Yue Qinyan. Effect of dosing method andpH on color removal performance and floc aggregation of polyferric chloride-polyamine dual-coagulant in synthetic dyeing wastewater treatment[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects,2010,355(1/2/3):121-129.
[13] Zhao He,Liu Huijian,Qu Jiuhui. Aluminum speciation of coagu-lants with low concentration: analysis by electrospray ionization mass spectrometry[J]. Colloids and Surfaces A:Physicochemicaland Engineering Aspects,2010,379(1/2/3):43-50.
[14] 李晔,陈新华,王建兵,等. PAC和PAM对造纸黑液混凝效果的研究[J]. 武汉理工大学学报,2002,24(9):45-47.
[15] Nasr H E,Farag A A,Sayyah S M,et al. Flocculation behavior of terpolymer prepared from dimethyl aminoethyl methacrylate,vinyl pyrrolidone,and vinylacetate using solution polymerization technique[J]. Journal of Dispersion Science and Technology,2010,31(4):427-437.

选择文件类型/文献管理软件名称

选择包含的内容

PAFC的制备及其在酸性红73废水处理中的应用

Preparation of polymeric aluminum ferric chloride flocculants and its application to the treatment of wastewater containing acid red 73

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	余俊龙, 穆超银, 雷钊, 高朝祥. 基于图像处理和模糊控制的絮凝剂智能投加系统设计[J]. 工业水处理, 2024, 44(6): 203-208.
[2]	赵晓娟, 张智瑞, 刘东洋, 雷彬. A²O工艺活性污泥黏性膨胀原因及控制措施[J]. 工业水处理, 2024, 44(4): 198-204.
[3]	严海源, 王昊龙, 管增富, 郭晓轩, 李斌, 于长伟, 孙建阳. 季铵化改性PAM及其在完井液废弃物处理中的应用[J]. 工业水处理, 2023, 43(6): 137-142.
[4]	赵诗琪, 李康辉, 陈猷鹏. 微生物絮凝剂及其在工业水处理中的应用探索[J]. 工业水处理, 2023, 43(2): 1-13.
[5]	李雪佳, 唐佳伟, 李杰, 郭强, 王小龙, 李井峰. 絮凝剂的研究进展及其在煤矿矿井水处理中的应用[J]. 工业水处理, 2023, 43(11): 93-103.
[6]	李强, 付鉴, 苏楠, 李为, 罗翔. 两性离子型聚合物絮凝剂的制备及性能评价[J]. 工业水处理, 2023, 43(1): 62-67.
[7]	陆永生, 徐喜旺, 冯威, 陈晨, 万俊锋. 绿锈-聚二甲基二烯丙基氯化铵絮凝剂的制备及应用[J]. 工业水处理, 2022, 42(5): 125-130.
[8]	王灵芝, 黄勇, 查晓, 张悦, 陈硕君, 王璐, 李大鹏. 利用污水污泥制备有机物聚集介质的可行性探析[J]. 工业水处理, 2022, 42(10): 22-30.
[9]	江南,雒鹏飞,童志明,陈武. 含钛聚硅酸盐絮凝剂的合成及处理压裂返排液研究[J]. 工业水处理, 2021, 41(5): 73-79.
[10]	宋翔,邢波,杨郭,袁基刚,刘兴勇. 以聚苯胺制备富含氮多孔碳催化氧化降解酸性红73[J]. 工业水处理, 2020, 40(9): 70-75.
[11]	谢慧娜,李杰,朱雪燕,边云峰. 响应面法优化混凝处理夏季高浊度黄河水[J]. 工业水处理, 2020, 40(2): 45-49.
[12]	李嘉,王刚,管映兵,徐敏. 2种新型重金属絮凝剂复配处理含铜废水[J]. 工业水处理, 2020, 40(1): 33-36.
[13]	蒋银峰, 蒋浩. 钢铁酸洗废液污染物质对污水处理效果的影响[J]. 工业水处理, 2019, 39(9): 54-57.
[14]	高树生, 张文柯, 丁秋炜, 王素芳, 姚光源. 改性壳聚糖类絮凝剂的合成及性能评价[J]. 工业水处理, 2019, 39(9): 91-93,107.
[15]	郭曼曼, 张宾, 马立标, 柳荣展. 聚丙烯酸絮凝剂在印染污泥低温热处理中的应用[J]. 工业水处理, 2019, 39(4): 29-32.

模态框（Modal）标题

选择文件类型/文献管理软件名称

选择包含的内容

PAFC的制备及其在酸性红73废水处理中的应用

Preparation of polymeric aluminum ferric chloride flocculants and its application to the treatment of wastewater containing acid red 73

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价