Salt-containing wastewater treatment by high-voltage capacitive adsorption of activated carbon fiber electrode insulated by organic film

doi:10.11894/1005-829x.2015.35(10).020

INDUSTRIAL WATER TREATMENT ›› 2015, Vol. 35 ›› Issue (10): 20-23. doi: 10.11894/1005-829x.2015.35(10).020

Previous Articles Next Articles

Salt-containing wastewater treatment by high-voltage capacitive adsorption of activated carbon fiber electrode insulated by organic film

Han Dan, Xu Youlin, Zhao Xianguang, Ren Peng, Xu Yanhua

School of Environment, Nanjing University of Technology, Nanjing 210009, China

Received:2015-07-13 Online:2015-10-20 Published:2015-10-22

活性炭纤维覆膜电极高电压电吸附处理含盐废水

韩丹, 徐有林, 赵贤广, 任朋, 徐炎华

南京工业大学环境学院, 江苏南京 210009

通讯作者: 赵贤广,电话:13851624491,E-mail:zxg174@163.com E-mail:zxg174@163.com
作者简介:韩丹(1987—),硕士研究生.电话:18262618473,E-mail:handan4480@126.com
基金资助:
国家太湖水专项基金项目(20082X07101-003)

Abstract

Abstract:

Aiming at the disadvantages of capacitive adsorption desalination process,such as low voltage,low treatment efficiency,easily corrosive electrode,etc.,the surface of activated carbon fiber electrode has been treated by membrane-coated insulation. The results from NaCl simulated solution experiment shows that in the membrane-coated electrode electro-adsorption desalination process,the optimal operation voltage is 20 V,and optimal reaction time 30 min. When the low-concentration NaCl solution is less than 300 mg/L,the electrical conductivity removing rate of the solution are above 80%. The result of electro-adsorption isotherm fitting shows that when the low voltage is less than 10 V,the adsorption tends to Langmuir model. When the voltage is high, the adsorption is in accordance with Freundlich model.

Key words: capacitive adsorption, activated carbon fiber electrode, insulating membrane, high voltage, desalination

摘要：

针对电容吸附除盐法中电压低、处理效率低、电极易腐蚀等缺点,对活性炭纤维电极表面进行了覆膜绝缘处理.NaCl模拟溶液实验结果表明,覆膜电极电吸附除盐的最佳操作电压为20 V,最佳作用时间为30 min.对低浓度NaCl溶液(<300 mg/L),溶液电导率去除率可达80%以上.吸附等温线拟合结果表明,低电压(<10 V)时,吸附倾向于Langmuir模型;高电压时,吸附更加符合Freundlich模型.

关键词: 电容吸附, 活性炭纤维电极, 绝缘膜, 高电压, 除盐

CLC Number:

X703.1

Han Dan, Xu Youlin, Zhao Xianguang, Ren Peng, Xu Yanhua. Salt-containing wastewater treatment by high-voltage capacitive adsorption of activated carbon fiber electrode insulated by organic film[J]. INDUSTRIAL WATER TREATMENT, 2015, 35(10): 20-23.

韩丹, 徐有林, 赵贤广, 任朋, 徐炎华. 活性炭纤维覆膜电极高电压电吸附处理含盐废水[J]. 工业水处理, 2015, 35(10): 20-23.

/ / Recommend / Download Citations

URL: https://www.iwt.cn/EN/10.11894/1005-829x.2015.35(10).020

https://www.iwt.cn/EN/Y2015/V35/I10/20

References

[1] Leonard K C,Genthe J R,Sanfilippo J L,et al. Synthesis and characterization of asymmetric electrochemical capacitive deionization materials using nanoporous silicon dioxide and magnesium doped aluminum oxide[J]. Electrochimica Acta,2009,54(22):5286-5291.
[2] Yang C M,Choi W H,Na B K,et al. Capacitive deionization of NaCl solution with carbon aerogel-silicagel composite electrodes[J]. Desalination,2005,174(2):125-133.
[3] Oren Y. Capacitive deionization(CDI) for desalination and water treatment:Past,present and future(a review)[J]. Desalination,2008, 228(1/2/3):10-29.
[4] Karagiannis I C,Soldatos P G. Water desalination cost literature:Review and assessment[J]. Desalination,2008,223(1):448-456.
[5] Al-Ahmad M,Aleem F A. Scale formation and fouling problems effect on the performance of MSF and RO desalination plants in Saudi Arabia[J]. Desalination,1993,93(1/2/3):287-310.
[6] Elimelech M,Phillip W A. The future of seawater desalination:Energy,technology,and the environment[J]. Science,2011,333:712-717.
[7] 宋卫峰,倪亚明,何德文. 电解法水处理技术的研究进展[J]. 化工环保,2001,21(1):11-15.
[8] Ryoo M W,Seo G. Improvement in capacitive deionization function of activated carbon cloth by titania modification[J]. Water Research, 2003,37(7):1527-1534.
[9] 常立民,段小月,刘伟. 载钛活性炭电极电吸附除盐性能的研究[J]. 环境科学学报,2010,30(3):530-535.
[10] Yan C,Zou L,Short R. Polyaniline-modified activated carbon electrodes for capacitive deionization[J]. Desalination,2014,333(1):101-106.
[11] 孙晓慰,朱国富. 电吸附水处理技术(EST)的原理及构成[J]. 工业用水与废水,2002,33(4):18-20.
[12] Johnson A M,Newman J. Desalting by means of porous carbon electrodes[J]. Journal of the Electrochemical Society,1971,118(3): 510-517.
[13] 刘海静,张鸿涛,孙晓慰. 电吸附法去除地下水中离子的试验研究[J]. 中国给水排水,2003,19(11):36-38.

[1]	Xiaozhuan CHEN, Dong LI, Man ZHAO, Yongfu LI. Research progress of scale inhibition by magnetic field, ultrasonic field and high voltage electrostatic field [J]. Industrial Water Treatment, 2025, 45(3): 22-33.
[2]	Jixiang YANG, Jinbing YANG, Longtian YIN, Jian DONG. Pilot study on heat pump coupled humidification-dehumidification for concentrated leachate treatment [J]. Industrial Water Treatment, 2025, 45(2): 144-149.
[3]	Xi HUAN, Wei WANG, Haobin JIN, Ziyu TIAN, Jingnan WANG, Gege HU, Siyuan KANG, Shuaili BAI. Preparation and interfacial evaporation properties of 3D photothermal absorber [J]. Industrial Water Treatment, 2025, 45(2): 78-84.
[4]	Chenyi YANG, Xikun ZHOU, Haopeng LUO, Fang JIANG, Huan CHEN. Progress on desalination technology of high salinity mine water [J]. Industrial Water Treatment, 2025, 45(2): 18-26.
[5]	Xuemin FENG, Xiaoqing ZHANG, Aijun ZHANG, Junrui CAO, Xiyuan KOU, Hanwen SONG, Jinquan QIU. Identification of the risk factors in concentrated seawater from seawater desalination process [J]. Industrial Water Treatment, 2024, 44(6): 53-59.
[6]	Jiemin SONG, Chengpeng WANG, Shenghui WANG, Jun LIU, Jiawen KOU, Yifan YANG, Xiugui TIAN. Specific energy consumption analysis of reverse osmosis desalination system with energy recovery combination processes [J]. Industrial Water Treatment, 2024, 44(5): 212-217.
[7]	Shuo YAN, Jun NAN, Xiaoyun LI, Yanfei LU, Qingbo WANG, Yanmin SUN, Yongmin ZHOU. Recent advances in MXene-based nanomaterials in water desalination field [J]. Industrial Water Treatment, 2024, 44(5): 64-70.
[8]	Bing XU, Xiaotong YANG, Jia LIU, Xu ZHANG, Xingjie YAO, Peixun GUO, Xinyu ZHANG. Research on sustainable off-grid desalination technology of solar interfacial evaporation [J]. Industrial Water Treatment, 2024, 44(4): 58-65.
[9]	Jun LIU, Yongqiang CHEN, Zhugen LIU, Xinhua REN, Zhixin LÜ, Haichao YU, Hongxia MING. Research progress on prevention and control of bio-fouling and early monitoring of reverse osmosis membrane in seawater desalination [J]. Industrial Water Treatment, 2024, 44(12): 12-19.
[10]	Jingze HU, Qingji WANG, Lin GAN, Jiacai XIE, Yilin WANG. Research progress on desalination treatment technology and resource utilization of saline organic wastewater in petroleum and petrochemical industry [J]. Industrial Water Treatment, 2024, 44(1): 32-43.
[11]	Yanmin QI, Xin LIU, Liming WANG, Shan SUN. Effects and countermeasures of desalination concentrated brine discharge on ecological environment [J]. Industrial Water Treatment, 2023, 43(4): 22-27.
[12]	Fuai CHEN, Ji’e NIU. Research on pathways and applications for solar thermal desalination [J]. Industrial Water Treatment, 2023, 43(3): 48-54.
[13]	Zekun YANG, Qingbai CHEN, Jianyou WANG, Yong XU, Yang GAO. Research progress of renewable energy-driven membrane desalination technology [J]. Industrial Water Treatment, 2023, 43(12): 14-25.
[14]	Jingguang CHEN, Nianlin FENG, Chongtao YU, Xin YANG, Li ZHOU. Influencing factors of seawater silt density index in Jiaozhou Bay [J]. Industrial Water Treatment, 2023, 43(11): 208-214.
[15]	Hongbin WANG, Shaozeng WANG, Yu ZHOU, Xuebing ZHU, Haiyan LI, Zhaoying XU, Shirong MU, Shaoxin KANG. Design and operation analysis of large-scale membrane seawater desalination system in coastal thermal power plant [J]. Industrial Water Treatment, 2023, 43(10): 174-178.

Please choose a citation manager

Content to export

Salt-containing wastewater treatment by high-voltage capacitive adsorption of activated carbon fiber electrode insulated by organic film

活性炭纤维覆膜电极高电压电吸附处理含盐废水

PDF

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

模态框（Modal）标题

Please choose a citation manager

Content to export

Salt-containing wastewater treatment by high-voltage capacitive adsorption of activated carbon fiber electrode insulated by organic film

活性炭纤维覆膜电极高电压电吸附处理含盐废水

PDF

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments