摘要：
染料废水具有"三高一低"的特点(高COD、高色度、高含盐量、低BOD5/COD),是废水治理的难点热点之一。在前期研究的工艺(混凝、气浮、水解酸化、好氧)基础上采用Fe/C微电解系统处理好氧池出水。结果表明:在pH为3.5,铁炭比1∶1.2,反应时间35 min的条件下,COD和色度的去除率分别稳定在80%和85%以上,出水中COD在60 mg/L以下,色度在42度以下,达到《GB 4287-1992纺织染整工业污染物排放标准》一级标准。
关键词:
染料废水,
Fe/C微电解,
混凝
Abstract:
Dye wastewater is characterized by "3-high and one-low":high COD,high chroma and high salinity;low BOD5/COD.It is one of the difficult points and hot spots in wastewater treatment.According to the research on the pocesses,such as coagulation,air flotation,anaerobic hydrolysis-acidification and oxic,Fe/C miroelectrolysis system has been used for treating the effluent water from aerobic tank.The results show that the removing rates of COD and chroma are over 80% and 85%,respectively under the conditions of pH 3.5,Fe/C ratio 1∶1.2 and reaction time 35 min.The COD concentration is below 60 mg/L and chroma in effluent is below 42 degree,reaching the first grade of Discharge Standard of the Pollutants in Dyeing and Finishing of Textile Industry(GB 4287-1992).
Key words:
dye wastewater,
Fe/C microelectrolysis,
coagulation
中图分类号:
邹海明, 于群英, 谢越, 王艳, 李飞跃. Fe/C微电解深度处理综合染料废水[J]. 工业水处理, 2012, 32(10): 16-19.
Zou Haiming, Yu Qunying, Xie Yue, Wang Yan, Li Feiyue. Advanced treatment of complex dye wastewater by Fe/C microelectrolysis[J]. INDUSTRIAL WATER TREATMENT, 2012, 32(10): 16-19.