好氧颗粒污泥的储存稳定性研究进展

doi:10.11894/1005-829x.2018.38(2).001

摘要/Abstract

摘要： 通过总结有关好氧颗粒污泥（AGS）储存及活性恢复的研究发现，AGS的储存技术包括原位储存和异位储存两类。原位储存过程中，AGS的理化特性明显恶化，活性显著下降。异位储存包括湿式储存和干式储存2种，常温湿式储存效果与原位储存相当；低温湿式储存及干式储存较有利于AGS结构完整性的保持，但也不能避免微生物活性的下降。另外，将储存后的AGS作为接种污泥可在短期内恢复正常。在此基础上，分析了现有研究的不足，并提出了建议。

关键词: 好氧颗粒污泥, 原位储存, 异位储存, 活性恢复

Abstract: Through the research regarding the summary of storage and reactivation of aerobic granular sludge(AGS), it is found that the storage technology of AGS includes two categories:in situ storage and ectopic storage. In the process of in situ storage,the physical and chemical characteristics of AGS get worse obviously,and its activity is decreased evidently. Ectopic storage includes two categories:wet-type storage and dry-type storage. The storage effect of the wet-type storage with normal temperature is quite the same as the effect of situ storage. Although wet-type storage at low temperature and dry-type storage are relatively beneficial to the maintenance of AGS structure integrality,the decrease of microbial activity is inevitable. In addition,the stored AGS as inoculated sludge can be reactivated in a short time. On this basis,the existing shortages of the research have been analyzed,and suggestions offered.

Key words: aerobic granule sludge, in situ storage, ectopic storage, reactivation

中图分类号:

X703

赵珏, 宣鑫鹏, 程媛媛, 龙焙, 郑洋洋, 陆晨露, 王智勇, 王华生. 好氧颗粒污泥的储存稳定性研究进展[J]. 工业水处理, 2018, 38(2): 1-5.

Zhao Jue, Xuan Xinpeng, Cheng Yuanyuan, Long Bei, Zheng Yangyang, Lu Chenlu, Wang Zhiyong, Wang Huasheng. Research progress in the storage stability of aerobic granular sludge[J]. INDUSTRIAL WATER TREATMENT, 2018, 38(2): 1-5.

https://www.iwt.cn/CN/Y2018/V38/I2/1

参考文献

[1] Show K Y,Lee D J,Tay J H. Aerobic granulation:Advances and challenges[J]. Applied Biochemistry and Biotechnology,2012,167(6):1622-1640.
[2] Lee D J,Chen Y Y,Show K Y,et al. Advances in aerobic granule formation and granule stability in the course of storage and reactor operation[J]. Biotechnology Advances,2010,28(6):919-934.
[3] 郝晓地,孙晓明,van Loosdrecht M. 好氧颗粒污泥技术工程化进展一瞥[J]. 中国给水排水,2011,27(20):9-12.
[4] Pronk M,de Kreuk M K,de Bruin B,et al. Full scale performance of the aerobic granular sludge process for sewage treatment[J]. Water Research,2015,84:207-217.
[5] Ni B J,Xie W M,Liu S G,et al. Granulation of activated sludge in a pilot-scale sequencing batch reactor for the treatment of low-strength municipal wastewater[J]. Water Research,2009,43(3):751-761.
[6] Wei Dong,Si Wei,Zhang Yongfang,et al. Aerobic granulation and nitrogen removal with the effluent of internal circulation reactor in start-up of a pilot-scale sequencing batch reactor[J]. Bioprocess and Biosystems Engineering,2012,35(9):1489-1496.
[7] Morales N,Figueroa M,Fra-Vázquez A,et al. Operation of an aero-bic granular pilot scale SBR plant to treat swine slurry[J]. Process Bio-chemistry,2013,48(8):1216-1221.
[8] Bai Long,Yang Changzhi,Pu Wenhong,et al. The treatment of solvent recovery raffinate by aerobic granular sludge in a pilot scale sequencing batch reactor[J]. Journal of Water and Health,2015,13(3):746-757.
[9] Sajjad M,Kim I S,Kim K S. Development of a novel process to miti-gate membrane fouling in a continuous sludge system by seeding aerobic granules at pilot plant[J]. Journal of Membrane Science,2016,497:90-98.
[10] 郭安,王然登,彭永臻. 好氧颗粒污泥形成及稳定运行的研究进展[J]. 水处理技术,2015,41(1):15-19.
[11] Zhang Quanguo,Hu Jianjun,Lee D J. Aerobic granular processes:Current research trends[J]. Bioresource Technology,2016,210:74-80.
[12] Liu Yu,Wang Zhiwu,Tay J H. A unified theory for upscaling aerobic granular sludge sequencing batch reactors[J]. Biotechnology Advances,2005,23(5):335-344.
[13] Pijuan M,Werner U,Yuan Z. Reducing the startup time of aerobic granular sludge reactors through seeding floccular sludge with crush-ed aerobic granules[J]. Water Research,2011,45(16):5075-5083.
[14] Verawaty M,Pijuan M,Yuan Z,et al. Determining the mechanisms for aerobic granulation from mixed seed of floccular and crushed granules in activated sludge wastewater treatment[J]. Water Re-search,2012,46(3):761-771.
[15] 熊光城,濮文虹,杨昌柱. 预加不同比例不同粒径好氧颗粒对SBR中好氧颗粒污泥形成的影响[J]. 环境科学,2013,34(4):1472-1478.
[16] Bai Long,Yang Changzhu,Pu Wenhong,et al. Rapid cultivation of aerobic granular sludge in a continuous flow reactor[J]. Journal of Environmental Chemical Engineering,2015,3(4):2966-2973.
[17] Bai Long,Yang Changzhu,Pu Wenhong,et al. Rapid cultivation of aerobic granule for the treatment of solvent recovery raffinate in a bench scale sequencing batch reactor[J]. Separation and Purifica-tion Technology,2016,160:1-10.
[18] Lim S J,Kim T H. Applicability and trends of anaerobic granular sludge treatment processes[J]. Biomass & Bioenergy,2013,60(1):189-202.
[19] Tay J H,Liu Q S,Liu Y. Characteristics of aerobic granules grown on glucose and acetate in sequential aerobic sludge blanket reac-tors[J]. Environmental Technology,2002,23(8):931-936.
[20] Zhu Jianrong,Wilderer P A. Effect of extended idle conditions on structure and activity of granular activated sludge[J]. Water Re-search,2003,37(9):2013-2018.
[21] Zhang Lili,Zhang Bo,Huang Yufeng,et al. Re-activation characteristics of preserved aerobic granular sludge[J]. Journal of Environ-mental Sciences,2005,17(4):655-658.
[22] 刘宏波,杨昌柱,濮文虹,等. 好氧颗粒污泥活性恢复的试验研究[J]. 中国给水排水,2008,24(19):16-19.
[23] Xu Huacheng,He Pinjing,Wang Guanzhao,et al. Enhanced storage stability of aerobic granules seeded with pellets[J]. Bioresource Technology,2010,101(21):8031-8037.
[24] 高景峰,苏凯,陈冉妮,等. 不同储存方法对好氧颗粒污泥恢复的影响[J]. 应用基础与工程科学学报,2011,19(3):408-415.
[25] Gao Dawen,Yuan Xiangjuan,Liang Hong. Reactivation performan-ce of aerobic granules under different storage strategies[J]. Water Research,2012,46(10):3315-3322.
[26] Yuan Xiangjuan,Gao Dawen,Liang Hong. Reactivation character-istics of stored aerobic granular sludge using different operational strategies[J]. Applied Microbiology and Biotechnology,2012,94(5):1365-1374.
[27] Zeng Ping,Zhuang Weiqin,Tay S T,et al. The influence of storage on the morphology and physiology of phthalic acid-degrading aero-bic granules[J]. Chemosphere,2007,69(11):1751-1757.
[28] 邵文华,徐颖,王惠卿. 好氧颗粒污泥快速恢复活性的试验研究[J]. 水资源与水工程学报,2011,22(4):46-49.
[29] Wan C,Zhang Q,Lee D J,et al. Long-term storage of aerobic gra-nules in liquid media:Viable but non-culturable status[J]. Bioresource Technology,2014,166(8):464-470.
[30] 陈垚,张志敏,袁绍春,等. 高盐好氧颗粒污泥低温储存后活性恢复研究[J]. 中国给水排水,2015,31(5):22-25.
[31] Adav S S,Lee D J,Lai J Y. Proteolytic activity in stored aerobic gra-nular sludge and structural integrity[J]. Bioresource Technology,2009,100(1):68-73.
[32] Tu Xiang,Su Bensheng,Li Xiaoning,et al. Characteristics of extra-cellular fluorescent substances of aerobic granular sludge in pilot-scale sequencing batch reactor[J]. Journal of Central South Univer-sity,2010,17(3):522-528.
[33] Lü Yi,Wan Chunli,Liu Xiang,et al. Freezing of aerobic granules for storage and subsequent recovery[J]. Journal of the Taiwan Insti-tute of Chemical Engineers,2013,44(5):770-773.
[34] Lü Yi,Wan Chunli,Liu Xiang,et al. Drying and re-cultivation of aerobic granules[J]. Bioresource Technology,2013,129(2):700-703.
[35] Hu Jianjun,Zhang Quanguo,Chen Y Y,et al. Drying and recovery of aerobic granules[J]. Bioresource Technology,2016,218:397-401.
[36] 唐朝春,简美鹏,刘名,等. 强化好氧颗粒污泥稳定性的研究进展[J]. 化工进展,2013,32(4):919-924.
[37] Wan Chunli,Lee D J,Yang Xue,et al. Saline storage of aerobic granules and subsequent reactivation[J]. Bioresource Technology,2014,172:418-422.
[38] Wan Chunli,Yang Xue,Lee D J,et al. Partial nitrification of waste-waters with high NaCl concentrations by aerobic granules in continuous-flow reactor[J]. Bioresource Technology,2013,152:1-6.
[39] Braeken K,Moris M,Daniels R,et al. New horizons for (p)ppGpp in bacterial and plant physiology[J]. Trends in Microbiology,2006, 14(1):45-54.
[40] 龙焙,濮文虹,杨昌柱,等. 不同生物选择段的SBR中好氧颗粒污泥的特性[J]. 中国给水排水,2015,31(5):16-21.
[41] 程媛媛,赵珏,王家辰,等. 设置生物选择段的SBR中好氧颗粒污泥的培养研究[J]. 中国给水排水,2016,32(21):17-22.
[42] Liu Yu,Yang Shufang,Tay J H. Improved stability of aerobic gra-nules by selecting slow-growing nitrifying bacteria[J]. Journal of Bio-technology,2004,108(2):161-169.
[43] Bai Long,Yang Changzhu,Pu Wenhong,et al. The stability of aero-bic granular sludge treating municipal sludge deep dewatering filtrate in a bench scale sequencing batch reactor[J]. Bioresource Technology,2014,169(5):244-250.
[44] 龙焙,濮文虹,杨昌柱,等. 失稳好氧颗粒污泥在SBR中的修复研究[J]. 中国给水排水,2015,31(7):29-33.
[45] 龙焙,杨腾飞,程媛媛,等. 高氨氮对连续流状态下好氧颗粒污泥稳定性的影响[J]. 中国给水排水,2017,33(3):12-17.
[46] 孙建华,戴荣继,邓玉林. 酶固定化技术研究进展[J]. 化工进展,2010,29(4):715-721.
[47] 欧阳丽华,周伟丽,张振家,等. 包埋固定化微生物的硫自养反硝化实验研究[J]. 环境科学,2011,32(6):1644-1652.
[48] 陈杰,汪霞,赵彬,等. A. faecalis strain NR的包埋固定及其氨氮降解性能[J]. 环境工程学报,2016,10(6):3303-3311.
[49] 徐颖,苏墨,邵文华,等. 好氧颗粒污泥储存后快速恢复活性最优条件的试验研究[J]. 工业水处理,2014,34(1):65-67.
[50] 闫立龙,刘玉,任源. 胞外聚合物对好氧颗粒污泥影响的研究进展[J]. 化工进展,2013,32(11):2744-2756.
[51] 王晓慧,刘永军,刘喆,等. 用三维荧光和红外技术分析好氧颗粒污泥形成初期胞外聚合物的变化[J]. 环境化学,2016,35(1):125-132.
[52] Heijnen J J,van Loosdrecht M C M,Mulder R,et al. Development and scale-up of an aerobic biofilm airlift suspension reactor[J]. Water Science and Technology,1993,27(5):253-261.

选择文件类型/文献管理软件名称

选择包含的内容